Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Carrier Inspection Air Brake SA Diesel Auto
- Inspected on
- 9/28/2026 12:10 PM
- Performed by
- Cody Schmitt
- Customer
- . . (Zip's)
- Repair Order
- J23816
- Vehicle
- 2012 International 4300
- VIN
- 1HTJTSKL1CH588806
- License Plate
- IA 664PYC
- Odometer
- 191,301mi
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
OK
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Parking Brake
OK
Steering Wheel Alignment
Warning
- Finding: Off to the left some
- Recommendation: Remove steering wheel and straighten
Drive Straight (Does Not Pull)
OK
Brakes Evenly
OK
Transmission Operation
OK
Vibration
OK
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Active ECM Error Codes
Notes
- Notes: none
Tires
Check & Adjust Tire Pressures, Record PSI
Notes
- Notes: 100psi
Visible Tire Alignment Wear
OK
Left Front Tire
OK
14 /32nds
Right Front Tire
OK
14 /32nds
Left Rear Inner Tire (Axle 1)
OK
17 /32nds
Left Rear Outside Tire (Axle 1)
OK
17 /32nds
Right Rear Outside Tire (Axle 1)
OK
17 /32nds
Right Rear Inside Tire (Axle 1)
OK
17 /32nds
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Notes
Notes
- Notes: Front shoes at 65%
- Rear shoes at 85%
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Notes
Notes
- Notes: RF Wheel seal leaking and the spindle is damp
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Spring Brake Cannister
OK
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Stainless Steel Wheel Simulators
Left Front Wheel
OK
Right Front Wheel
OK
Left Rear Wheel (Drive Axle 1)
OK
Right Rear Wheel (Drive Axle 1)
OK
Wheel Seals
Underhood
Radiator
OK
Radiator Cap
OK
Power Steering Fluid Condition
OK
Transmission Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Additional Drive Belts - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Air Filter
OK
Fuel Filter - Primary
OK
Fuel Filter - Secondary
OK
Engine
Engine Fan
Fan Blade Assembly
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Front Suspension HD
King Pins
OK
Front Springs
OK
Rear Suspension HD
Radius Arms
OK
Air Bag Suspension Operation
OK
No-Start - Cranks Over
Battery Test
OK
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Charged?
OK
Alternator Wiring
OK
Voltage Drop - Batt Pos to Alternator
0 Volts
Voltage Drop - Batt Neg to Block
0 Volts
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
OK
3-ID Lights
OK
License Plate Light
OK
Back Up Alarm
OK
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
OK
Fuel Tank Mounting Brackets
OK
Automatic Transmission
Operation
OK
Oil Leaks
OK
Filter
OK
Chassis Driveline
Hanger Bearings
OK
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
Warning
- Finding: Rear differential Fill/ check plug wet.
- Recommendation: Clean and Reseal
Chassis Exterior Condition
Grille
OK
Hood Latch
OK
Cowl
OK
Back of Cab
OK
Roof
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
Warning
- Finding: Dented, sligthly bent, and starting to rust.
- Recommendation: Noted
Fuel Tanks
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Switch Panel
OK
Driver Seat Cushion
OK
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Chassis Has More Than 100,000 Miles
OK
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Windshield
OK
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
Warning
- Finding: Left mirror does not go up and down.
- Recommendation: Repair
Right Mirror
Warning
- Finding: Right mirror does not go up and down.
- Recommendation: Check for bad switch
Spot Mirrors
OK
Windshield Wipers
Left Wiper
Warning
- Finding: Blade is Worn
- Recommendation: Replace Blade
Right Wiper
Warning
- Finding: Blade is worn
- Recommendation: Replace blade
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Chassis Notes
Steering Heavy Duty
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Steering Sector
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Power Take-Off
PTO Mounting Bolts To Transmission
OK
PTO Warning Light
OK
Oil Leak From Main Shaft
OK
PTO Noisey
OK
PTO Shift Mechanism
OK
Wheel Lift
Wear Pads
OK
Pivot Pin
OK
Lift Cylinder
OK
Extension Cylinder
OK
Left L-Arm
OK
Right L-Arm
OK
Left Slide Tray
OK
Right Slide Tray
OK
Inner Stinger
OK
Cross Bar
OK
Outer Tube
OK
Wheel-Lift Hold Down Straps
OK
Notes
Notes
- Notes: Wheel lift straps were missing. Replaced with new.
Carrier Body Lighting
Cab Mounted Marker Lights
OK
Control Station Lights
OK
Emergency Main Beacon Lightbar
OK
Lower Work Lights
OK
Rear Tail / Brake Lights
OK
Rear Turn Signals
OK
Side Marker Lights
OK
Stop Tail Turn Lights In Beacon
OK
Upper Work Lights
OK
Winch Mounted Work Lights
OK
Carrier Body Lubrication
Winch Oil Level
OK
Car Carrier Aluminum Deck
Carrier Hydraulic Cylinders
Tilt Cylinders
Warning
- Finding: Holding valve wet.
- Recommendation: Clean and find source of leak
Bed Extension Cylinder
Warning
- Finding: End cap is damp
- Recommendation: Clean and recheck.
Car Carrier Bed Hold-Down
Frame Mounted Hold Down
OK
Car Carrier Tail Light Housing
Driver Side Tail Light Housing
OK
Car Carrier Mounting Bolts and Framework
Bolts or Mounting Issues
Notes
- Notes: None
Car Carrier Controls
Driver Side Control Levers
Warning
- Finding: A little play
- Recommendation: none
Passenger Side Control Levers
Warning
- Finding: A little play.
- Recommendation: none
Control Valve
Warning
- Finding: Damp.
- Recommendation: Clean and inspect.
Control Station Decal
OK
Valve Pressure
OK
Driver Side Control Box
OK
Passenger Side Control Box
OK
Anti-Tilt Plate
OK
Cross Over Control Housing
OK
Red Arrow - Bed Tilt Decal
OK
Car Carrier Tool Box
Driver Side Front Box
OK
Passenger Side Front Box
OK
Hydraulic Hoses
General/Unknown Hose Leaks
Notes
- Notes: none
Winch Hose Leaks
OK
Bed Lift Cylinder Hose Leaks
OK
Bed Extension Cylinder Hoses
OK
Wheel-Lift Tilt Cylinder Hose Leaks
OK
Hydraulic Pump Hoses
OK
Wheel-lift Extension Hoses
OK
Control Valve Hose To Tank
OK
Car Carrier Wiring
Carrier Wiring Dangling
OK
Bed Wiring Intermittant
OK
Wiring In Hose Tray
OK
Junction Box
OK
Hydraulic Pump
Oil Leak
OK
Hydraulic Pressure
OK
Check & Record Hydraulic Pressure Reading(S)
Notes
- Notes: 2800
Tow Light Kit
Magnetic Tow Light Cord
OK
Light Module
OK
Wireless Tow Light Sender
OK
Wireless Tow Light Housing
OK
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Car Carrier Pylon
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Winch (Single)(Driver Side)
Oil Leak
Warning
- Finding: Wet around check plug on side of housing.
- Recommendation: Reseal plug and check upper case vent.
Gearbox Vent - Free of Paint & debris
OK
Grease Free Spool Linkage
OK
Change Oil In Gearbox
OK
Oil Level In Gearbox
OK
Free Wheel Mechanism
OK
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
OK
Carrier Standard Accessories
J-Chains In Vehicle
OK
V-Chain Or V-Strap In Vehicle
OK
Tow Light Kit In Vehicle
OK
Flare Kit In Vehicle
OK
Fire Extinguisher in Vehicle
OK
Safety Chains
OK
Vehicle Tie Down Strap Kit
OK
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
Problem
- Notes: Right front wheel seal needs replaced.
Cody Schmitt, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.