Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Carrier Inspection Air Brake SA Diesel Auto
- Inspected on
- 4/29/2026 2:47 PM
- Performed by
- Jesse Bergmann
- Customer
- . .
- Repair Order
- J23411
- Vehicle
- 2021 Ford F-750
- VIN
- 1FDWX7DE6MDF04535
- License Plate
- IA
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
OK
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Parking Brake
OK
Wind Noise
OK
Steering Wheel Alignment
OK
Brakes Evenly
OK
Transmission Operation
OK
Vibration
OK
ECM Reading
Mileage on ECM
Notes
- Notes: 241,355
Tires
Check & Adjust Tire Pressures, Record PSI
Notes
- Notes: Adjusted Tire PSI
Left Front Tire
OK
18 /32nds
Right Front Tire
OK
18 /32nds
Left Rear Inner Tire (Axle 1)
OK
19 /32nds
Left Rear Outside Tire (Axle 1)
OK
19 /32nds
Right Rear Outside Tire (Axle 1)
OK
17 /32nds
Right Rear Inside Tire (Axle 1)
OK
16 /32nds
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Spring Brake Cannister
OK
Wheels and Hardware
Nuts Checked for Proper Torque?
OK
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
OK
Power Steering Fluid Condition
OK
Transmission Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Additional Drive Belts - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Air Filter
OK
Fuel Filter - Primary
OK
Fuel Filter - Secondary
OK
Engine
Engine Oil Leaks
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
OK
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Steering Light Duty
Steering Box
OK
Power Steering Hoses
OK
Power Steering Pump
OK
Steering Linkage
OK
Idler Arm
OK
Steering Damper
OK
Center Link
OK
Adjusting Sleeves
OK
Outer Tie Rod Ends
OK
Front Suspension HD
Front Springs
OK
Rear Suspension HD
Rear Springs
OK
Radius Arms
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Load Test
OK
Battery Charged?
OK
Alternator Output Test
OK
Alternator Wiring
OK
Voltage Drop - Batt Pos to Alternator
OK
Voltage Drop - Batt Neg to Block
OK
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Greased King Pins
OK
Greased Tie Rod Ends
OK
Greased Springs
OK
Greased Driveshaft Bearings
OK
Oil Filled Hubs To Proper Level
OK
Rear Differential Oil Levels Full
OK
Windshield Washer Level Full?
OK
Engine Oil Filter Life
OK
Air Dryer Filter
OK
Anti-Freeze Test to -30
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
OK
3-ID Lights
OK
License Plate Light
OK
Back Up Alarm
OK
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
OK
Fuel Tank Mounting Brackets
OK
Automatic Transmission
Operation
OK
Oil Leaks
OK
Filter
OK
Chassis Driveline
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Chassis Exterior Condition
Hood
OK
Grille
OK
Fender Extensions
OK
Hood Latch
OK
Hood Springs
OK
Cowl
OK
Left Cab Corner
Problem
- Finding: Dented
- Recommendation: Repair
Roof
OK
Drivers Door
Problem
- Finding: A few small dents and chips.
- Recommendation: Repair
Passenger Door
Problem
- Finding: A few dents
- Recommendation: Repair
Left Fender
OK
Right Fender
OK
OEM Front Bumper
Problem
- Finding: Bent and scratched
- Recommendation: Replace if desired
Driver Side Rear Door
OK
Passenger Side Rear Door
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Switch Panel
OK
Driver Seat Cushion
OK
Drive Seat Back
OK
Passenger Seat Cushion
Warning
- Finding: Worn
- Recommendation: Replace
Passenger Seat Back
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Arm Rest
Warning
- Finding: Minor damage
- Recommendation: Noted
Driver Door Arm Rest
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Rear Seat
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Exhaust Fluid Level
OK
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Windshield
OK
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
OK
Right Mirror
OK
Spot Mirrors
OK
Rear View In-Cab Mirror
OK
Windshield Wipers
Left Wiper
OK
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Steering Heavy Duty
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Steering Sector
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Fan
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Transmission Oil Temperature
OK
Main Air Pressure Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Air Filter Gauge
OK
Low Air Pressure Warning Buzzer
OK
PTO Warning Light
OK
Fuel Gauge
OK
Intake Manifold Heater
OK
Camera
Aftermarket Camera
OK
Power Take-Off
PTO Warning Light
OK
Oil Leak From Main Shaft
OK
Wheel Lift
Wear Pads
OK
Pivot Pin
OK
Lift Cylinder
OK
Extension Cylinder
OK
Left L-Arm
OK
Right L-Arm
OK
Right Hand Claw Cylinder
OK
Inner Stinger
OK
Left Hand Claw Cylinder
OK
Cross Bar
OK
Right Hand Claw
OK
Left Hand Claw
OK
Auto Grip Claw Pins
OK
Left Auto Grip Claw Cylinder Pivot
OK
Right Auto Grip Cylinder Pivot
OK
Outer Tube
OK
Carrier Body Lighting
Control Station Lights
OK
Emergency Main Beacon Lightbar
OK
Grill Mounted Strobe Lights
OK
In Cab Mounted Emergency Lighting
OK
Lower Work Lights
OK
Rear Facing Strobes
OK
Rear Tail / Brake Lights
OK
Rear Turn Signals
OK
Side Marker Lights
OK
Stop Tail Turn Lights In Beacon
OK
Upper Work Lights
OK
Winch Mounted Work Lights
OK
Carrier Body Lubrication
Sub-Frame And Long Sill Lubrication
OK
Tilt Cylinder Pins
OK
Hydraulic Filter
OK
Hydraulic Fluid
OK
Winch Oil Level
OK
Extension Cylinder Pins
OK
Main Bed Pivot Pin At Rear
OK
Car Carrier Steel Deck
Steel Deck Floor Condition
OK
Steel Deck Cross Members
OK
Deck Outer Rail
OK
Long Sill
OK
Rear Approach Plate
OK
Bed Wear Pads
OK
Carrier Steel Deck Floor Paint Condition
Paint on Floor
OK
Carrier Hydraulic Cylinders
Tilt Cylinders
OK
Bed Extension Cylinder
OK
Above Cab Rack Cylinders
OK
Car Carrier Tail Light Housing
Driver Side Tail Light Housing
OK
Passenger Side Tail light housing
OK
Car Carrier Controls
Driver Side Control Levers
OK
Passenger Side Control Levers
OK
Control Valve
OK
Control Station Decal
OK
Valve Pressure
OK
Driver Side Control Box
OK
Passenger Side Control Box
OK
Anti-Tilt Plate
OK
Cross Over Control Housing
OK
Red Arrow - Bed Tilt Decal
OK
Car Carrier Tool Box
Driver Side Front Box
OK
Passenger Side Front Box
OK
Hydraulic Hoses
Bed Lift Cylinder Hose Leaks
OK
Bed Extension Cylinder Hoses
OK
Wheel-Lift Tilt Cylinder Hose Leaks
OK
Hydraulic Pump Hoses
OK
Wheel-lift Extension Hoses
OK
Wheel-Lift Claw Cylinder Hoses
OK
Car Carrier Wiring
Carrier Wiring Dangling
OK
Bed Wiring Intermittant
OK
Wiring In Hose Tray
OK
Junction Box
OK
Hydraulic Pump
Oil Leak
OK
Hydraulic Pressure
OK
Remote Hydraulic Controls
Remote Control Hand Held Unit
OK
Tow Light Kit
Magnetic Tow Light Cord
OK
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Car Carrier Pylon
Pylon Center Cab Protector
OK
Pylon Paint Condition
OK
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Left Side Auxiliary Beacon
OK
Winch (Single)(Driver Side)
Oil Leak
OK
Gearbox Vent - Free of Paint & debris
OK
Grease Free Spool Linkage
OK
Free Wheel Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
OK
Carrier Standard Accessories
J-Chains In Vehicle
OK
V-Chain Or V-Strap In Vehicle
OK
Tow Light Kit In Vehicle
OK
Fire Extinguisher in Vehicle
OK
Vehicle Tie Down Strap Kit
OK
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
OK
Jesse Bergmann, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.