Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Bob Parrott.
Small Wrecker Inspection Hydraulic Brake
- Inspected on
- 4/3/2024 1:47 PM
- Performed by
- Jeff Parrott
- Customer
- . . (Zips Truck Equipment)
- Repair Order
- J21336
- Vehicle
- 2017 Ford F-450
- VIN
- 1FD0X4HT2HEE73345
- License Plate
- Odometer
- 210,806mi
Priority Items
Safety: These items can contribute to dangerous driving conditions or breakdowns
Tire Size and Brand
- Technician's Notes: 225/70 R19.5 BLACKHAWK
Windshield
Problem
- Finding: Chipped
- Recommendation: Dt Randy Wickman
Side Marker Lights
Problem
(Resolved)
- Finding: Bed lights missing and inop
- Recommendation: Replace and repair
Winch Cable
Problem
(Resolved)
- Finding: Cable eye is damaged
- Recommendation: Replace
Safety Chains
Problem
(Resolved)
- Finding: Missing safety clasp.
- Recommendation: Repair.
Performance: These items in need of attention affect the performance of this piece of equipment
Right L-Arm
Problem
(Resolved)
- Finding: Pins missing
- Recommendation: Replace
Right Hand Claw
Problem
(Resolved)
- Finding: Pin and bushing are worn
- Recommendation: Replace/repair
Auto Grip Claw Pins
Problem
(Resolved)
- Finding: Missing claws
- Recommendation: Replace with claws and crossbar
Right Auto Grip Cylinder Pivot
Problem
(Resolved)
- Finding: Missing
- Recommendation: Replace with claws and crossbar
Maintenance: These items are recommended to increase the life of your vehicle and to lower the cost of ownership
Is The Check Engine Light Off?
Problem
Engine Oil Level/Condition
Problem
(Resolved)
- Finding: No oil on dipstick
- Recommendation: Change
Battery Cables
Warning
(Resolved)
- Finding: Corrosion
- Recommendation: Service battery & cables
Fuel Filter - Primary
Problem
(Resolved)
- Finding: Needs changed
- Recommendation: Replace
Fuel Filter - Secondary
Problem
(Resolved)
- Finding: Filter change recommended
- Recommendation: Replace filter
Battery Cables
Warning
(Resolved)
- Finding: Cable ends need cleaned.
- Recommendation: Clean cable ends.
Is The Check Engine Light Off?
Problem
- Technician's Notes: adblue/def control module
Greased Tie Rod Ends
Warning
- Finding: Need greased
- Recommendation: Grease them
Engine Oil To Full Mark?
Problem
(Resolved)
- Finding: Low and needs changed
- Recommendation: Change oil and filter
Windshield Washer Level Full?
Problem
(Resolved)
- Finding: Low
- Recommendation: Top it off
Engine Oil Filter Life
Problem
(Resolved)
- Finding: Needs changed
- Recommendation: Change
Fuel Filter Life
Problem
(Resolved)
- Finding: Filter change recommended
- Recommendation: Change
DPF Warning Light
Problem
- Finding: Warning Light On
- Recommendation: Diagnose and repair
Chassis Has More Than 100,000 Miles
Problem
- Finding: Check if it has been serviced.
- Recommendation: Revisit.
Inner Stinger
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Pivot Pin
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Claw Pivots
Problem
(Resolved)
- Finding: Grease
- Recommendation: Grease
Up/Down Lift Mechanism
Problem
(Resolved)
- Finding: Needs to be greased
- Recommendation: Grease
Wheel Lift Tilt Pivot
Problem
(Resolved)
- Finding: Grease
- Recommendation: Grease
Wheel Lift Tilt Cylinder
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Boom End Pulley(s)
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Lift Cylinder Pins
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease It
Free Wheel Mechanism
Problem
(Resolved)
- Finding: Stuck/froze
- Recommendation: Free up and lube
Cosmetics: These items involve issues more of appearance than of use.
Hood
Warning
- Finding: Cracks and scratches
- Recommendation: Buff and repair
Back of Cab
Problem
- Finding: Damaged
- Recommendation: Repair/repaint
Drivers Door
Warning
- Finding: A few dents
- Recommendation: Repair
Passenger Door
Warning
- Finding: A few dents
- Recommendation: Repair
OEM Front Bumper
Warning
- Finding: Bumper Damaged
- Recommendation: Replace Front Bumper
Driver Side Rear Door
Warning
- Finding: Door Damaged
- Recommendation: Repair and Repaint Door
Passenger Side Rear Door
Warning
- Finding: Dented
- Recommendation: Nothing at this time
Comfort: These items will not affect the drivability or life of the car, but make driving it easier
Cabin Air Filter
Problem
(Resolved)
- Finding: Filter Dirty
- Recommendation: Replace Filter
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Hood Springs
Problem
(Resolved)
- Finding: Bad struts
- Recommendation: Replace
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Parking Brake
OK
Wind Noise
OK
Steering Wheel Alignment
OK
4x4 Four Wheel Drive Work?
OK
Drive Straight (Does Not Pull)
OK
Brakes Evenly
OK
Transmission Operation
OK
Vibration
OK
Computer Error Codes
Is The ABS Light Off?
OK
Tires
Visible Tire Alignment Wear
OK
Left Front Tire
Problem
4 /32nds
(Resolved)
- Finding: Tire wear
- Recommendation: Replac
Right Front Tire
Problem
0 /32nds
(Resolved)
- Finding: Tire wear
- Recommendation: Replace
Left Rear Inner Tire (Axle 1)
OK
15 /32nds
Left Rear Outside Tire (Axle 1)
OK
15 /32nds
Right Rear Outside Tire (Axle 1)
OK
15 /32nds
Right Rear Inside Tire (Axle 1)
OK
15 /32nds
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Disc)
OK
Right Front Brakes (Disc)
OK
Left Rear Brakes (Disc)
OK
Right Rear Brakes (Disc)
OK
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Emergency Brake Drum & Pads
OK
Emergency Brake Foot Pedal Mechaism
OK
Emergency Brake Cable
OK
Wheels and Hardware
Nuts Checked for Proper Torque?
OK
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Brake Fluid Condition
OK
Power Steering Fluid Condition
OK
Transmission Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Additional Drive Belts - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Air Filter
OK
Ignition Components
OK
Engine
Engine Oil Leaks
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Glow Plugs
OK
Engine Performance
OK
Engine Fan
Fan Blade Assembly
OK
Fan Shroud
OK
Fan Belt
OK
Viscous Fan Operation
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Steering Light Duty
Rack/Boots
OK
Power Steering Hoses
OK
Steering Linkage
OK
Idler Arm
OK
Steering Damper
OK
Center Link
OK
Adjusting Sleeves
OK
Inner Tie Rod Ends
OK
Outer Tie Rod Ends
OK
Front Suspension Light Duty
Front Coil Springs
OK
Lower Control Arm Bushings
OK
Upper Control Arm Bushings
OK
Upper Ball Joints
OK
Lower Ball Joints
OK
Shocks/Struts
OK
Pitman Arm
OK
Stabilizer Bar
OK
Lock-Out Hubs
OK
Rear Suspension Light Duty
Rear Springs
OK
Stabilizer Bar
OK
Charging/Starting/Battery Systems OLD
Battery Load Test
OK
Battery Charged?
OK
Alternator Output Test
OK
Alternator Wiring
OK
Amperage Draw @ Battery
OK
Warning Lights in Dash
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Transmission Oil Level Full?
OK
Rear Differential Oil Levels Full
OK
Power Steering Oil Level Full
OK
Brake Fluid Level Full?
OK
Engine Coolant Level Full?
OK
Anti-Freeze Test to -30
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
OK
License Plate Light
OK
Back Up Alarm
Warning
- Finding: Speaker needs cleaned
- Recommendation: Clean
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
OK
Fuel Tank Mounting Brackets
OK
Transfer Case
Transfer Case
OK
Transfer Case Mounting
OK
Automatic Transmission
Operation
OK
Oil Leaks
OK
Chassis Driveline
Hanger Bearings
OK
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Chassis Exterior Condition
Grille
OK
Fender Extensions
OK
Hood Latch
OK
Cowl
OK
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Left Fender
OK
Right Fender
OK
Fuel Tanks
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Switch Panel
OK
Driver Seat Cushion
OK
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Passenger Seat Suspension
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Horn (on Steering Wheel)
OK
Shifter Boot
OK
Rear Seat
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
Exhaust Fluid Level
OK
Frame Components
Frame Rails
OK
Glass
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
OK
Right Mirror
OK
Spot Mirrors
OK
Rear View In-Cab Mirror
OK
Windshield Wipers
Left Wiper
OK
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Fan
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Transmission Oil Temperature
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
PTO Warning Light
OK
Fuel Gauge
OK
DEF Fluid Gauge
OK
Power Take-Off
PTO Warning Light
OK
Oil Leak From Main Shaft
OK
PTO Noisey
OK
PTO Shift Mechanism
OK
Wheel Lift
Wear Pads
OK
Pivot Pin
OK
Lift Cylinder
OK
Tilt Cylinder
OK
Extension Cylinder
OK
Left L-Arm
OK
Right Hand Claw Cylinder
OK
Inner Stinger
OK
Left Hand Claw Cylinder
OK
Left Hand Claw
OK
Left Auto Grip Claw Cylinder Pivot
OK
Outer Tube
OK
Wrecker Main Frame
Free Of Cracks / Broken Welds
OK
Mounting Plate Condition
OK
Mounting Plate Bolts Tight
OK
Wrecker Boom
Check Each Boom Stage / Outer Tube For Straightness
OK
Boom Wear Pads
OK
Boom Free Of Cracks / Broken Welds
OK
Boom Extend Cylinder Operation
OK
Boom Pivot Pin
OK
Boom Lift Cylinder Pins
OK
Boom Lift Cylinders
OK
Hydraulic lines mounted under boom condition
OK
Wrecker Controls
Remote Control
OK
Control Valve
OK
Wrecker Body Lighting
Rear Tail/Brake Lights
OK
Under Body Flood Lights
OK
Pylon Mounted Flood Lights
OK
Cab Mounted Marker Lights
OK
Emergency Beacon Main
OK
Wrecker Body Lubrication
Main Boom Pivot
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease It
Hydraulic Hoses
Wheel-lift Extension Hoses
OK
Wheel-Lift Claw Cylinder Hoses
OK
Control Valve Hose To Tank
OK
Hydraulic Pump
Hydraulic Pressure
OK
Remote Hydraulic Controls
Wired Remote Cable
OK
Wiring At Control Valve
OK
Control Valve Solenoid
OK
Dollies
Dolly Tires
OK
Dolly Frames
OK
Wheel Bearings
OK
Dolly Rims
OK
Wheel Studs
OK
Cross Bars
OK
Lever Bar
OK
Dolly Frame Mounting Bracket
OK
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Winch (Single)(Driver Side)
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Wrecker Body Condition
Light Pylon
OK
Back-Up Alarm
Back Up Alarm
OK
Jeff Parrott, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.