Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Bob Parrott.
Wrecker Tandem or Tri-Axle
- Performed by
- Austin Liddle
- Customer
- Zips Truck
- Repair Order
- J20373
- Vehicle
- 2016 Peterbuilt 330
- VIN
- 2NP2HJ7X0GM368629
- License Plate
- IA
- Odometer
- 26,882mi
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
Problem
(Resolved)
- Finding: Find air air leak
- Recommendation: Fix air leak
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
ECM Reading
Mileage on ECM
- Technician's Notes: 27,583
Engine Hours
- Technician's Notes: 1,502
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Tires
Check & Adjust Tire Pressures, Record PSI
- Technician's Notes: .
Visible Tire Alignment Wear
OK
Tire Size and Brand
- Technician's Notes: 11r22.5 bridgestone
Left Front Tire
Problem
(Resolved)
- Finding: Side walls cracking
- Recommendation: Replace
Right Front Tire
Problem
(Resolved)
- Finding: Side walls cracking
- Recommendation: Replace
Left Rear Inner Tire (Axle 1)
Problem
(Resolved)
- Finding: Side wall cracking
- Recommendation: Replace
Left Rear Outside Tire (Axle 1)
Problem
(Resolved)
- Finding: Side wall cracking
- Recommendation: Replace
Right Rear Outside Tire (Axle 1)
Problem
(Resolved)
- Finding: Sidewall cracking
- Recommendation: Replace
Right Rear Inside Tire (Axle 1)
Problem
(Resolved)
- Finding: Sidewall cracking
- Recommendation: Replace
Notes
(Resolved)
- Technician's Notes: All 6 tires cracking, Drive tires are choppy. Replace all 6 tires!
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Spring Brake Cannister
OK
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
Warning
- Finding: Red overspray.
- Recommendation: Buff off.
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Stainless Steel Wheel Simulators
Left Front Wheel
OK
Right Front Wheel
OK
Left Rear Wheel (Drive Axle 1)
Problem
(Resolved)
- Finding: Missing
- Recommendation: Replace
Right Rear Wheel (Drive Axle 1)
OK
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
Problem
(Resolved)
- Finding: Over full and black.
- Recommendation: T.b.d.
Power Steering Fluid Condition
OK
Transmission Fluid Condition
Problem
(Resolved)
- Finding: Transmission Fluid low
- Recommendation: Refill and check for leaks
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
0 Qty
Air Filter
Problem
(Resolved)
- Finding: Air Filter is dirty
- Recommendation: Replace Filter
Cabin Air Filter
OK
More Information...
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Fuel Filter - Primary
Problem
(Resolved)
- Finding: Filter change recommended
- Recommendation: Change filter
Fuel Filter - Secondary
Problem
(Resolved)
- Finding: Filter change recommended
- Recommendation: Replace filter
Engine
Engine Oil Leaks
OK
Doesn't Start
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Glow Plugs
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
OK
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Front Suspension HD
King Pins
OK
Front Springs
Warning
(Resolved)
- Finding: Bushings showing some wear.
- Recommendation: T.b.d.
Rear Suspension HD
Radius Arms
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
No-Start - Cranks Over
Fuel Level
OK
Battery Test
Warning
(Resolved)
- Finding: Need to Load Test
- Recommendation: Load Test
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Load Test
OK
11.4 Volts
Battery Charged?
OK
Alternator Wiring
OK
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Greased King Pins
Problem
(Resolved)
- Finding: Need greased
- Recommendation: Grease them
Greased Tie Rod Ends
Problem
(Resolved)
- Finding: Need greased
- Recommendation: Grease them
Greased Driveshaft Bearings
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease them
Engine Oil To Full Mark?
Problem
(Resolved)
- Finding: Needs changed
- Recommendation: Change oil and filter
Oil Filled Hubs To Proper Level
OK
Transmission Oil Level Full?
OK
Rear Differential Oil Levels Full
Problem
(Resolved)
- Finding: Low
- Recommendation: Fill back to proper level
Power Steering Oil Level Full
OK
Windshield Washer Level Full?
OK
Engine Coolant Level Full?
Problem
(Resolved)
- Finding: Low
- Recommendation: Top off
Engine Oil Filter Life
Problem
(Resolved)
- Finding: Needs to be changed with the oil
- Recommendation: Change it
Fuel Filter Life
Problem
(Resolved)
- Finding: Filter life unknown
- Recommendation: Replace filter
Air Dryer Filter
OK
Anti-Freeze Test to -30
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
Problem
(Resolved)
- Finding: Don't work
- Recommendation: Fix them
3-ID Lights
OK
License Plate Light
OK
Back Up Alarm
Problem
(Resolved)
- Finding: Inop
- Recommendation: Diagnose and repair
Fuel System
Automatic Transmission
Operation
OK
Oil Leaks
Problem
(Resolved)
- Finding: Needs cleaning to determine
- Recommendation: Clean and inspect
Filter
Problem
(Resolved)
- Finding: Should be changed
- Recommendation: Replace
Chassis Driveline
Hanger Bearings
OK
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Chassis Exterior Condition
Hood
OK
Grille
Warning
- Finding: Chrome peeling
- Recommendation: Nothing at this time
Fender Extensions
OK
Hood Springs
OK
Cowl
OK
Back of Cab
Warning
(Resolved)
- Finding: Suspension shock is wore out.
- Recommendation: Replace shock.
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Drivers Door
OK
Passenger Door
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
OK
Fuel Tanks
Problem
(Resolved)
- Finding: Stuff growing in the tank with debris.
- Recommendation: Clean and treat tank.
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Driver Seat Cushion
OK
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Chassis Has More Than 100,000 Miles
OK
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Windshield
Warning
(Resolved)
- Finding: Bunch of surface chips
- Recommendation: Repair/replace windshield
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
OK
Right Mirror
OK
Spot Mirrors
OK
Rear View In-Cab Mirror
Problem
(Resolved)
- Finding: "Step Mirror" on pass door broken
- Recommendation: Replace
Windshield Wipers
Left Wiper
Problem
(Resolved)
- Finding: Blade is Worn
- Recommendation: Replace Blade
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
Problem
(Resolved)
- Finding: Antenna is not working
- Recommendation: Repair or replace
Radio Speaker
OK
Chassis Notes
Steering Heavy Duty
Steering Wheel Centered Properly
OK
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Freon Level
OK
Air Dryer
Air Dryer
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Fan
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Main Air Pressure Gauge
OK
Secondary Air Pressure Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Low Air Pressure Warning Buzzer
OK
PTO Warning Light
Problem
- Finding: Inop
- Recommendation: Repair
Fuel Gauge
OK
DEF Fluid Gauge
OK
Camera
Aftermarket Camera
OK
Power Take-Off
PTO Mounting Bolts To Transmission
OK
Oil Leak From Main Shaft
Problem
(Resolved)
- Finding: Leaking
- Recommendation: Diagnose and fix
PTO Noisey
OK
PTO Shift Mechanism
OK
Wheel Lift
Load Test Wheel Lift - Extend & Retract Under Load
Warning
(Resolved)
- Finding: Unable to retract or tilt with lift extended
- Recommendation: Make necessary repairs to lift and re test
Wear Pads
Problem
(Resolved)
- Finding: Missing lower wear pads
- Recommendation: Replace
Pivot Pin
Warning
- Finding: Has some play
- Recommendation: Noted
Lift Cylinder
OK
Tilt Cylinder
OK
Extension Cylinder
Warning
(Resolved)
- Finding: Walks in and out after function has been released.
- Recommendation: Diagnose.
Left L-Arm
OK
Right L-Arm
OK
Left Slide Tray
OK
Right Slide Tray
Warning
(Resolved)
- Finding: T bolt is missing
- Recommendation: Replace
Inner Stinger
OK
Outer Tube
OK
Wheel-Lift Hold Down Straps
Problem
(Resolved)
- Finding: Ratchet and straps look questionable.
- Recommendation: To be determined.
Wheel-lift Forks (Number of Sets)
7 Qty
Fork Receiver
OK
Wrecker Main Frame
Free Of Cracks / Broken Welds
OK
Mounting Plate Condition
OK
Mounting Plate Bolts Tight
OK
Wrecker Boom
Check Each Boom Stage / Outer Tube For Straightness
OK
Boom Wear Pads
OK
Boom Free Of Cracks / Broken Welds
OK
Boom Extend Cylinder Operation
OK
Boom Pivot Pin
OK
Boom Lift Cylinder Pins
OK
Boom Lift Cylinders
OK
Hydraulic lines mounted under boom condition
OK
Wrecker Outrigger Legs
Driver's Side Rear Outrigger
OK
Passenger Side Rear Outrigger
OK
Wrecker Controls
Wrecker Body Lighting
Side Marker Lights
OK
Rear Tail/Brake Lights
OK
Under Body Flood Lights
Problem
(Resolved)
- Finding: Right light missing
- Recommendation: Replace
Tool Box Interior Lights
OK
Grille Mounted Strobe Lights
Warning
(Resolved)
- Finding: Strobe pattern is not set right.
- Recommendation: Set pattern.
Emergency Beacon Main
OK
Wrecker Body Lubrication
Inner Stinger
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Pivot Pin
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Up/Down Lift Mechanism
Problem
(Resolved)
- Finding: Needs to be greased
- Recommendation: Grease
Wheel Lift Tilt Pivot
Problem
(Resolved)
- Finding: Needs to be greased
- Recommendation: Grease
Wheel Lift Tilt Cylinder
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Boom End Pulley(s)
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease it
Lift Cylinder Pins
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease It
Tool Box Doors, Latches and Locks
Problem
(Resolved)
- Finding: Lube latches
- Recommendation: Lube
Main Boom Pivot
Problem
(Resolved)
- Finding: Needs greased
- Recommendation: Grease It
Hydraulic Hoses
Winch Hose Leaks
OK
Bed Lift Cylinder Hose Leaks
OK
Wheel-Lift Tilt Cylinder Hose Leaks
OK
Hydraulic Pump Hoses
OK
Wheel-lift Extension Hoses
OK
Control Valve Hose To Tank
OK
Hydraulic Pump
Oil Leak
OK
Remote Hydraulic Controls
Remote Control Hand Held Unit
Problem
(Resolved)
- Finding: Missing
- Recommendation: Replace
Wiring At Control Valve
OK
Control Valve Solenoid
OK
Tow Light Kit
Magnetic Tow Light Cord
Problem
- Finding: Missing
- Recommendation: Replace
Wireless Tow Light Sender
Problem
(Resolved)
- Finding: Sender Missing
- Recommendation: Replace Sender
Wireless Tow Light Housing
Problem
(Resolved)
- Finding: Missing tow light
- Recommendation: Replace
Fenderettes
Driver Side Fenderette
OK
Passenger Side Fenderette
OK
Mudflaps
Driver Side Mudflap
Warning
(Resolved)
- Finding: Non-zip mudflaps
- Recommendation: Replace with zip mudflaps
Passenger Side Mudflap
Warning
(Resolved)
- Finding: Non-zip mudflaps
- Recommendation: Replace with zip mudflaps
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Winch (Single)(Driver Side)
Load Test Winch & Winch Brake
OK
Oil Leak
OK
Gearbox Vent - Free of Paint & debris
OK
Oil Level In Gearbox
OK
Air Free Wheel Control
OK
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
Warning
(Resolved)
- Finding: Pull out and inspect cable
- Recommendation: Replace if necessary
Winch Passenger Side (or Top Deck)
Load Test Winch & Winch Brake
OK
Oil Leak
OK
Gearbox Vent - Free of Paint & debris
OK
Air Free Wheel Control
OK
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
Warning
(Resolved)
- Finding: Pull out and inspect cable
- Recommendation: Replace if necessary
Wrecker Body Condition
Wrecker Standard Accessories
Flare Kit
OK
- Technician's Notes: Triangles
Fire Extinguisher
OK
- Technician's Notes: Mount loose and hard to access
Safety Chains
Problem
(Resolved)
- Finding: One side missing hook
- Recommendation: Replace hook
Snatch Blocks
Quantity of Snatch Blocks
0 Qty
Back-Up Alarm
Back Up Alarm
Problem
(Resolved)
- Finding: Back Up Alarm Inoperative
- Recommendation: Repair or Replace
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
OK
Austin Liddle, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.