Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Carrier Inspection Air Brake SA Diesel Auto
- Inspected on
- 9/23/2026 5:52 AM
- Performed by
- Jim Reams
- Customer
- . .
- Repair Order
- J23836
- Vehicle
- 2026 Freightliner M2
- VIN
- 3ALACWFC9TDWJ9289
- License Plate
- IA
- Odometer
- 87,173mi
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
Problem
- Finding: Low Air Light Comes On, But No Sound Or Alarm
- Recommendation: Nothing at this time, Still Passes DOT
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
OK
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Parking Brake
OK
Wind Noise
OK
Steering Wheel Alignment
OK
Drive Straight (Does Not Pull)
OK
Brakes Evenly
OK
Transmission Operation
OK
Vibration
OK
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Tires
Check & Adjust Tire Pressures, Record PSI
Notes
- Notes: Need to check
Tire Size and Brand
Notes
- Notes: Milestar in front Rear mismatched
Left Front Tire
OK
18 /32nds
Right Front Tire
OK
18 /32nds
Left Rear Inner Tire (Axle 1)
Warning
7 /32nds
- Finding: Miss match tire
- Recommendation: Replace
Left Rear Outside Tire (Axle 1)
OK
13 /32nds
Right Rear Outside Tire (Axle 1)
OK
14 /32nds
Right Rear Inside Tire (Axle 1)
Problem
5 /32nds
- Finding: Miss matched
- Recommendation: Replace
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Stainless Steel Wheel Simulators
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
Problem
- Finding: Change
- Recommendation: Change
Transmission Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
1 Qty
Air Filter
Problem
- Finding: Air Filter is dirty
- Recommendation: Replace Filter
Cabin Air Filter
Problem
- Finding: Filter Dirty
- Recommendation: Replace Filter
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Fuel Filter - Primary
Problem
- Finding: Needs changed
- Recommendation: Replace
Fuel Filter - Secondary
Problem
- Finding: Filter change recommended
- Recommendation: Change filter
Engine
Engine Oil Leaks
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Glow Plugs
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
Problem
- Finding: Filter change recommended
- Recommendation: Change filter
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Front Suspension HD
King Pins
OK
Front Springs
OK
Air Bag Suspension
OK
Rear Suspension HD
Rear Springs
OK
Radius Arms
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
No-Start - Cranks Over
Fuel Level
OK
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Charged?
OK
Alternator Output Test
OK
14.1 Amps
Alternator Wiring
OK
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Greased King Pins
Warning
- Finding: Need greased
- Recommendation: Grease them
Greased Tie Rod Ends
Warning
- Finding: Grease
- Recommendation: Grease
Greased Driveshaft Bearings
Warning
- Finding: Grease
- Recommendation: Grease
Engine Oil To Full Mark?
Problem
- Finding: Change oil
- Recommendation: Change
Oil Filled Hubs To Proper Level
OK
Transmission Oil Level Full?
OK
Rear Differential Oil Levels Full
OK
Power Steering Oil Level Full
OK
Windshield Washer Level Full?
Problem
- Finding: Low
- Recommendation: Top it off
Engine Coolant Level Full?
OK
Engine Oil Filter Life
Problem
- Finding: Needs changed
- Recommendation: Change
Fuel Filter Life
Problem
- Finding: Filter change recommended
- Recommendation: Change
Air Dryer Filter
OK
Anti-Freeze Test to -30
OK
Steering Sector Oil Full
OK
Chassis Lighting
Hi/Low Head Lamp Switch
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
OK
3-ID Lights
OK
License Plate Light
OK
Back Up Alarm
Problem
- Finding: Does Not Work
- Recommendation: Repair / Replace
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
OK
Fuel Tank Mounting Brackets
OK
Automatic Transmission
Operation
OK
Oil Leaks
OK
Filter
OK
Chassis Driveline
Hanger Bearings
OK
Intermediate Universal Joint
Warning
- Finding: Needs grease
- Recommendation: Grease
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Chassis Exterior Condition
Fender Extensions
OK
Hood Latch
OK
Hood Springs
OK
Back of Cab
OK
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Drivers Door
OK
Passenger Door
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
OK
Fuel Tanks
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Switch Panel
OK
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Passenger Seat Suspension
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Chassis Has More Than 100,000 Miles
OK
Exhaust Fluid Level
OK
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
OK
Right Mirror
OK
Spot Mirrors
OK
Windshield Wipers
Left Wiper
OK
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Steering Heavy Duty
Steering Wheel Centered Properly
OK
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Steering Sector
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Freon Level
OK
Air Dryer
Air Dryer
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Fan
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Main Air Pressure Gauge
OK
Secondary Air Pressure Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Low Air Pressure Warning Buzzer
Problem
- Finding: Inop
- Recommendation: Repair
PTO Warning Light
OK
Fuel Gauge
OK
DEF Fluid Gauge
OK
Intake Manifold Heater
OK
Camera
Aftermarket Camera
Problem
- Finding: Camera works but the glass is broken.
- Recommendation: Replace.
Power Take-Off
PTO Mounting Bolts To Transmission
OK
PTO Warning Light
OK
Oil Leak From Main Shaft
OK
PTO Noisey
OK
PTO Shift Mechanism
OK
Wheel Lift
Wear Pads
OK
Pivot Pin
OK
Lift Cylinder
OK
Tilt Cylinder
OK
Extension Cylinder
OK
Right Hand Claw Cylinder
OK
Inner Stinger
OK
Left Hand Claw Cylinder
OK
Cross Bar
OK
Right Hand Claw
OK
Left Hand Claw
OK
Auto Grip Claw Pins
OK
Left Auto Grip Claw Cylinder Pivot
OK
Right Auto Grip Cylinder Pivot
OK
Outer Tube
OK
Wheel-Lift Hold Down Straps
Problem
- Finding: Missing
- Recommendation: Replace
Carrier Body Lighting
Cab Mounted Marker Lights
OK
Control Station Lights
Problem
- Finding: Both sides inop
- Recommendation: Replace
Lower Work Lights
OK
Rear Tail / Brake Lights
OK
Rear Turn Signals
OK
Side Marker Lights
OK
Stop Tail Turn Lights In Beacon
OK
Upper Work Lights
OK
Carrier Body Lubrication
Sub-Frame And Long Sill Lubrication
Warning
- Finding: Needs greased
- Recommendation: Grease
Tilt Cylinder Pins
Warning
- Finding: Needs greased
- Recommendation: Grease
Hydraulic Filter
OK
Hydraulic Fluid
OK
Extension Cylinder Pins
Warning
- Finding: Needs greased
- Recommendation: Greased
Main Bed Pivot Pin At Rear
Warning
- Finding: Needs greased
- Recommendation: Grease
Car Carrier Steel Deck
Steel Deck Cross Members
OK
Deck Outer Rail
Warning
- Finding: Make sure they come out
- Recommendation: Fix
Long Sill
OK
Rear Approach Plate
OK
Bed Wear Pads
OK
Carrier Steel Deck Floor Paint Condition
Paint on Floor
Warning
- Finding: Floor is Rusty
- Recommendation: Paint Floor
Carrier Hydraulic Cylinders
Tilt Cylinders
OK
Bed Extension Cylinder
OK
Car Carrier Bed Hold-Down
Frame Mounted Hold Down
OK
Car Carrier Removable Rails
Steel Rails
Warning
- Finding: Make sure they come out
- Recommendation: Tbd
Car Carrier Tail Light Housing
Driver Side Tail Light Housing
OK
Car Carrier Controls
Driver Side Control Levers
OK
Passenger Side Control Levers
OK
Control Valve
OK
Control Station Decal
OK
Valve Pressure
OK
Driver Side Control Box
OK
Passenger Side Control Box
OK
Cross Over Control Housing
OK
Red Arrow - Bed Tilt Decal
OK
Car Carrier Tool Box
Driver Side Front Box
Warning
- Finding: Key is Missing
- Recommendation: Replace Key
Hydraulic Hoses
Winch Hose Leaks
OK
Bed Lift Cylinder Hose Leaks
OK
Bed Extension Cylinder Hoses
OK
Wheel-Lift Tilt Cylinder Hose Leaks
OK
Hydraulic Pump Hoses
OK
Wheel-lift Extension Hoses
OK
Wheel-Lift Claw Cylinder Hoses
OK
Control Valve Hose To Tank
OK
Car Carrier Wiring
Carrier Wiring Dangling
OK
Bed Wiring Intermittant
OK
Wiring In Hose Tray
OK
Junction Box
OK
Hydraulic Pump
Oil Leak
OK
Hydraulic Pressure
OK
Check & Record Hydraulic Pressure Reading(S)
Notes
- Notes: 2300 psi
Remote Hydraulic Controls
Remote Control Hand Held Unit
OK
Tow Light Kit
Magnetic Tow Light Cord
Problem
- Finding: Missing
- Recommendation: Replace
Wireless Tow Light Sender
Problem
- Finding: Missing tow light
- Recommendation: Replace
Wireless Tow Light Housing
Problem
- Finding: Missing tow light
- Recommendation: Replace
Fenderettes
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Car Carrier Pylon
Pylon Center Cab Protector
OK
Winch (Single)(Driver Side)
Load Test Winch & Winch Brake
OK
Oil Leak
OK
Gearbox Vent - Free of Paint & debris
OK
Oil Level In Gearbox
OK
Free Wheel Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
OK
Carrier Standard Accessories
J-Chains In Vehicle
Problem
- Notes: Missing
V-Chain Or V-Strap In Vehicle
Problem
- Notes: Missing
Tow Light Kit In Vehicle
Problem
- Notes: Missing
Flare Kit In Vehicle
OK
Fire Extinguisher in Vehicle
OK
Safety Chains
OK
Vehicle Tie Down Strap Kit
OK
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
Problem
- Notes: Windshield
Jim Reams, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.