Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Truck Tractor Inspection
- Inspected on
- 3/10/2026 1:09 PM
- Performed by
- Randy Slick
- Customer
- . .
- Repair Order
- J23214
- Vehicle
- 2021 Peterbuilt 330
- VIN
- 1XPXD49X3MD752590
- License Plate
- IA
- Odometer
- 416,407mi
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
OK
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Jake Brake Operation
OK
Parking Brake
OK
Wind Noise
OK
Steering Wheel Alignment
OK
Drive Straight (Does Not Pull)
OK
Locking Differential Rear Axle
OK
Brakes Evenly
OK
Transmission Operation
OK
Clutch Operation
OK
Vibration
OK
ECM Reading
Mileage on ECM
Notes
- Notes: 401,160 miles off ECM
Engine Hours
Notes
10602.9 hrs
- Notes: 10602.9 hrs off ECM
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Tires
Check & Adjust Tire Pressures, Record PSI
Notes
- Notes: Set Pressures 120 psi for front axle and 110 psi for rear axle
All Tires
OK
15 /32nds
Tire Size and Brand
Notes
- Notes: Front Axle - Falken RI130 285/75R24.5 120 psi
- Drive Axles - Ironhead IDL290-FS 285/75R24.5 110 psi
Left Front Tire
OK
15 /32nds
Right Front Tire
OK
15 /32nds
Left Rear Inner Tire (Axle 1)
Warning
15 /32nds
- Finding: Choppy
- Recommendation: Rotate tires possible alignment issue
Left Rear Outside Tire (Axle 1)
Warning
15 /32nds
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Left Rear Outside Tire (Axle 2)
Warning
15 /32
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Left Rear Inner Tire (Axle 2)
Warning
15 /32
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Right Rear Outside Tire (Axle 1)
Warning
15 /32nds
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Right Rear Inside Tire (Axle 1)
Warning
15 /32nds
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Right Rear Outside Tire (Axle 2)
Warning
15 /32
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Right Rear Inside Tire (Axle 2)
Warning
15 /32
- Finding: Choppy
- Recommendation: Rotate tires and possible alignment issue
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Left Rear Brakes (Drive Axle 2) Air
OK
Right Rear Brakes (Drive Axle 2) Air
OK
Notes
Notes
- Notes: All axles are air over disc brakes all rotors look good as well
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Rear Wheel (Drive Axle 2) Brake Lines
OK
Right Rear Wheel (Drive Axle 2) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Rear Wheel (Drive Axle 2) Brake Chamber
OK
Right Rear Wheel(Drive Axle 2)Brake Chamber
OK
Left Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Rear Wheel (Drive Axle 2) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 2) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Left Rear Wheel(D.A.2)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.2)Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Left Rear Wheel (Drive Axle 2) Shock
OK
Right Rear Wheel (Drive Axle 2) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Spring Brake Cannister
OK
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Rear Wheel (Drive Axle 2) Rims
OK
Right Rear Wheel (Drive Axle 2) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Left Rear Wheel (Drive Axle 2) Axle Studs
OK
Right Rear Wheel (Drive Axle 2) Axle Studs
OK
Stainless Steel Wheel Simulators
Left Front Wheel
OK
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Left Rear Wheel (Drive Axle 2) Wheel Seal
OK
Right Rear Wheel (Drive Axle 2) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
OK
Power Steering Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Air Filter
OK
Cabin Air Filter
OK
More Information...
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Fuel Filter - Primary
OK
Fuel Filter - Secondary
OK
Engine
Engine Oil Leaks
OK
Doesn't Start
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Glow Plugs
OK
Manifold Heater
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
OK
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Filter
OK
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Front Suspension HD
King Pins
OK
Front Springs
OK
Rear Suspension HD
Rear Springs
OK
Radius Arms
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Charged?
OK
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Greased King Pins
OK
Greased Tie Rod Ends
OK
Greased Springs
OK
Greased Driveshaft Bearings
OK
Engine Oil To Full Mark?
OK
Oil Filled Hubs To Proper Level
OK
Transmission Oil Level Full?
OK
Rear Differential Oil Levels Full
OK
Power Steering Oil Level Full
OK
Windshield Washer Level Full?
OK
Engine Coolant Level Full?
OK
Engine Oil Filter Life
OK
Fuel Filter Life
OK
Air Dryer Filter
OK
Anti-Freeze Test to -30
OK
Steering Sector Oil Full
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
OK
License Plate Light
OK
Back Up Alarm
OK
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
OK
Fuel Tank Mounting Brackets
OK
Chassis Driveline
Hanger Bearings
OK
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Rear Differential #2
OK
Chassis Exterior Condition
Hood
OK
Grille
OK
Hood Latch
OK
Hood Springs
OK
Back of Cab
OK
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Drivers Door
OK
Passenger Door
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
OK
Fuel Tanks
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
OK
Chassis Interior Cab Components
Driver Seat Cushion
OK
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Passenger Seat Suspension
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Clutch Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Shifter Boot
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Chassis Has More Than 100,000 Miles
OK
Manual Transmission
Shifting Operation
OK
Clutch Operation
OK
Transmission Grinds Into First Gear
OK
Throw-Out Bearing Noise
OK
Oil Leaks
OK
Bell Housing
OK
Input Shaft
OK
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Windshield
OK
Left Door Glass
OK
Right Door Glass
OK
Mirrors
Left Mirror
OK
Right Mirror
OK
Windshield Wipers
Left Wiper
OK
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Sleeper
Mattress Covers
OK
Mattress
OK
Steering Heavy Duty
Steering Wheel Centered Properly
OK
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Steering Sector
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Freon Level
OK
Air Dryer
Air Dryer
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Transmission Oil Temperature
OK
Rear End #1 Temperature Gauge
OK
Main Air Pressure Gauge
OK
Secondary Air Pressure Gauge
OK
Air Suspension Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Rear End #2 Temperature Gauge
OK
Air Filter Gauge
OK
Low Air Pressure Warning Buzzer
OK
PTO Warning Light
OK
Fuel Gauge
OK
DEF Fluid Gauge
OK
Power Take-Off
PTO Mounting Bolts To Transmission
OK
Oil Leak From Main Shaft
OK
PTO Noisey
OK
Air Leak At PTO
OK
PTO Shift Mechanism
OK
Fenderettes
Driver Side Fenderette
Problem
- Finding: Dent runs pretty much the whole fender. With rust starting to set in
- Recommendation: Replace with new ones
Passenger Side Fenderette
Problem
- Finding: Dent run pretty much the whole fenders. Rust starting to set in
- Recommendation: Replace with new ones
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Couplers
Fifth Wheel-Plate & Mount
Warning
- Finding: Fifth wheel needs grease.
- Recommendation: Clean and grease.
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
OK
Randy Slick, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.