Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Wrecker Tandem or Tri-Axle
- Inspected on
- 3/28/2025 1:53 PM
- Performed by
- Austin Liddle
- Customer
- . .
- Repair Order
- J20374
- Vehicle
- 2012 Peterbilt 389
- VIN
- 1NPXX4TX8CD164788
- License Plate
- IA
- Odometer
- 489,627mi
Pre-Trip In Cab Air Brake Test
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Cruise Control
OK
Proper Acceleration and Engine Performance
OK
Jake Brake Operation
OK
Wind Noise
OK
Steering Wheel Alignment
Problem
- Finding: Not centerd
- Recommendation: Adjust
Drive Straight (Does Not Pull)
Problem
- Finding: You have to constantly 'Chase" the steering wheel to keep it straight
- Recommendation: Check steering components out
Brakes Evenly
OK
Transmission Operation
OK
Clutch Operation
Problem
- Finding: Engages at last two inches of travel.
- Recommendation: Repair/replace
Vibration
Warning
- Finding: Some vibration under a load
- Recommendation: Diagnose.
ECM Reading
Mileage on ECM
- Technician's Notes: 489,095
Engine Hours
- Technician's Notes: 21,478
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Active ECM Error Codes
- Technician's Notes: Trans and drive temp.
- 17703/7703
Tires
Check & Adjust Tire Pressures, Record PSI
- Technician's Notes: Psi.
Visible Tire Alignment Wear
Warning
- Finding: Rear tires are choppy
- Recommendation: Rec alignment
Tire Size and Brand
- Technician's Notes: Steer axle
- 315/80R22.5 Roadmaster
- D.a. 1-2
- 11R24.5 Double Coin
Left Front Tire
OK
23 /32nds
Right Front Tire
OK
23 /32nds
Left Rear Inner Tire (Axle 1)
OK
25 /32nds
Left Rear Outside Tire (Axle 1)
OK
25 /32nds
Left Rear Outside Tire (Axle 2)
OK
23 /32
Left Rear Inner Tire (Axle 2)
OK
24 /32
Right Rear Outside Tire (Axle 1)
OK
29 /32nds
Right Rear Inside Tire (Axle 1)
OK
25 /32nds
Right Rear Outside Tire (Axle 2)
OK
24 /32
Right Rear Inside Tire (Axle 2)
OK
23 /32
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Left Rear Brakes (Drive Axle 2) Air
Problem
- Finding: Linings are deteriorated.
- Recommendation: Replace.
Right Rear Brakes (Drive Axle 2) Air
Problem
- Finding: Linings are deteriorated.
- Recommendation: Replace.
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
Problem
- Finding: Brake line is a hydraulic hose.
- Recommendation: Replace.
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
Problem
- Finding: lines wore thin
- Recommendation: replace
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Rear Wheel (Drive Axle 2) Brake Lines
OK
Right Rear Wheel (Drive Axle 2) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
Problem
- Finding: Spring broken
- Recommendation: Replace chamber
Left Rear Wheel (Drive Axle 2) Brake Chamber
OK
Right Rear Wheel(Drive Axle 2)Brake Chamber
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
Problem
- Finding: S-cam strap is broken.
- Recommendation: Replace strap.
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Left Rear Wheel(D.A.2)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.2)Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
Problem
- Finding: Leaking from seal
- Recommendation: Replace shocks on steer axle
Right Front Shock
Problem
- Finding: Leaking
- Recommendation: Replce
Left Rear Wheel (Drive Axle 1) Shock
Problem
- Finding: Shock Absorber Bad
- Recommendation: Replace drive axle shocks
Right Rear Wheel (Drive Axle 1) Shock
Problem
- Finding: Shock Absorber Bad
- Recommendation: Replace Shock
Left Rear Wheel (Drive Axle 2) Shock
Problem
- Finding: Shock Absorber Bad
- Recommendation: Replace Shock
Right Rear Wheel (Drive Axle 2) Shock
Problem
- Finding: Shock Absorber Bad
- Recommendation: Replace Shock
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Rear Wheel (Drive Axle 2) Rims
OK
Right Rear Wheel (Drive Axle 2) Rims
OK
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Left Rear Wheel (Drive Axle 2) Wheel Seal
OK
Right Rear Wheel (Drive Axle 2) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
Problem
- Finding: Needs to be changed
- Recommendation: Change oil and filter
Power Steering Fluid Condition
Problem
- Finding: Fluid is dirty.
- Recommendation: Change/flush oil and change filter.
Transmission Fluid Condition
Warning
- Finding: Oil condition is good but a little low
- Recommendation: Top off.
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
Problem
2 Qty
- Finding: Belts cracked and worn
- Recommendation: Replace belts
Air Filter
Problem
- Finding: Air Filter Dirty
- Recommendation: Replace Filter
Cabin Air Filter
Problem
- Finding: Filter dirty
- Recommendation: Wash filter
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Fuel Filter - Primary
Problem
- Finding: Filter change recommended
- Recommendation: Change filter
Fuel Filter - Secondary
Problem
- Finding: Filter change recommended
- Recommendation: Change filter
Engine
Engine Oil Leaks
Problem
- Finding: Underside of motor is covered in oil
- Recommendation: Steam clean to figure out where the leaks are coming from
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
Problem
- Finding: Filter change recommended
- Recommendation: Change filter
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Air Compressor
Air Compressor
OK
Power Steering
Power Steering Filter
Problem
- Finding: Filter change recommended.
- Recommendation: Change filter
Power Steering Pump
Problem
- Finding: Power steering is weak.
- Recommendation: Diagnose and repair.
Power Steering Hoses
OK
Front Suspension HD
Front Springs
Problem
- Finding: Bushings are bad.
- Recommendation: Must replace.
Rear Suspension HD
Rear Springs
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
No-Start - Cranks Over
Fuel Level
OK
Battery Test
Warning
- Finding: Cranks over slow first rotatons.
- Recommendation: Test cranking amps.
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Charged?
OK
Alternator Wiring
Warning
- Finding: Corrosion at connectors to alternator. Not charging
- Recommendation: Clean ends of wire
Warning Lights in Dash
Is The Check Engine Light Off?
Problem
- Technician's Notes: Error appears on startup then clears.
Is The ABS Light Off?
OK
Is The Water Temp Warning Light Off?
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
OK
Turn Signal Lights
OK
Interior Cab Courtesy Lights
Warning
- Finding: Drivers light is inop.
- Recommendation: Repair.
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
Problem
- Finding: Alarm inop no lights
- Recommendation: Diagnose and repair
3-ID Lights
OK
License Plate Light
Problem
- Finding: Gone
- Recommendation: Replace
Back Up Alarm
Problem
- Finding: Does Not Work
- Recommendation: Repair / Replace
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
Warning
- Finding: Drivers side tank dented
- Recommendation: Inspect and replace if needed
Fuel Tank Mounting Brackets
OK
Chassis Driveline
Hanger Bearings
Warning
- Finding: Front hanger bearing rubber is loose
- Recommendation: Replace
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
Problem
- Finding: Bearing is loose.
- Recommendation: Repair.
Intermediate Yoke
Warning
- Finding: Yoke is loose
- Recommendation: Repair
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
Warning
- Finding: Low on fluid
- Recommendation: Fill up to proper level
Rear Differential #2
Warning
- Finding: Low on oil.
- Recommendation: Top off
Chassis Exterior Condition
Grille
OK
Hood Latch
OK
Back of Cab
OK
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Drivers Door
OK
Passenger Door
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
OK
Fuel Tanks
OK
Passenger Side Cab Entry Steps
OK
Notes
- Technician's Notes: Hood bent below the windshield.
Chassis Interior Cab Components
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Clutch Pedal Pad
Warning
- Finding: Worn
- Recommendation: Usable
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
OK
Passenger Side Electric/Air Window
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Air Horn
OK
Horn (on Steering Wheel)
OK
Shifter Boot
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Notes
- Technician's Notes: Missing Obd port nut.
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Flex Tubing
OK
Elbows
OK
Tubing
OK
Engine Manifold
Problem
- Finding: One broken exhaust manifold bolt/gasket leaking
- Recommendation: Replace gaskets.
Exhaust Mounting Brackets
Warning
- Finding: Broken clamp on down pipe off turbo
- Recommendation: Replace
DPF System
DPF Warning Light
OK
Chassis Has More Than 100,000 Miles
Warning
- Finding: Chassis does have more than 100,000mi
- Recommendation: To be determined by RW
Manual Transmission
Shifting Operation
OK
Clutch Operation
Problem
- Finding: Improper Free-Play
- Recommendation: Adjust Clutch and Linkage
Oil Leaks
OK
Bell Housing
Warning
- Finding: Missing service cover
- Recommendation: Replace
Frame Components
Frame Rails
OK
Air Suspension Valve
OK
Glass
Windshield
OK
Left Door Glass
Warning
- Finding: Dark tinted
- Recommendation: Remove
Right Door Glass
Warning
- Finding: Dark tinted
- Recommendation: Remove
Rear Window
OK
Mirrors
Left Mirror
Warning
- Finding: Electric mirror not working properly.
- Recommendation: Fix or replace
Right Mirror
Warning
- Finding: Electric motor does not work
- Recommendation: Fix
Spot Mirrors
OK
Windshield Wipers
Left Wiper
Warning
- Finding: Bad
- Recommendation: Replace it
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Chassis Notes
Steering Heavy Duty
Steering Wheel Centered Properly
Problem
- Finding: Steering Wheel Not Centered
- Recommendation: Recheck when suspension repaired
Tie Rod Ends
Warning
- Finding: Inspect closely.
- Recommendation: Noted.
Drag Link
Problem
- Finding: Ends loose
- Recommendation: Replace link
Pitman Arm
OK
Steering Column
OK
Steering Sector
Warning
- Finding: Power steering loss.
- Recommendation: Inspect system.
Power Steering Oil Lines
OK
Alternator
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
Problem
- Finding: AC inop
- Recommendation: Diagnose and repair
Air Conditioning Compressor
Problem
- Finding: Appears to be leaking
- Recommendation: Check for leaks
Air Compressor Belt
Problem
- Finding: Belt cracked
- Recommendation: Replace
Freon Level
Problem
- Finding: System Low on Freon
- Recommendation: None
Air Dryer
Air Dryer
Problem
- Finding: filter needs replaced because of age
- Recommendation: Replace
Cab Heater
Heater Controls
OK
Fan Motor
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Transmission Oil Temperature
OK
Rear End #1 Temperature Gauge
OK
Main Air Pressure Gauge
OK
Secondary Air Pressure Gauge
OK
Pusher Axle Air Pressure Gauge
OK
Air Suspension Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Rear End #2 Temperature Gauge
OK
Low Air Pressure Warning Buzzer
OK
Fuel Gauge
OK
DEF Fluid Gauge
OK
Camera
Notes
- Technician's Notes: Not equipped.
Power Take-Off
PTO Warning Light
Warning
- Finding: No light installed
- Recommendation: Add if wanted
Oil Leak From Main Shaft
Problem
- Finding: Has oil all over it
- Recommendation: Clean and check for leak
PTO Noisey
OK
Air Leak At PTO
OK
PTO Shift Mechanism
OK
Wheel Lift
Wear Pads
Problem
- Finding: Need replaced
- Recommendation: Replace
Pivot Pin
Warning
- Finding: A little sloppy
- Recommendation: T.b.d.
Tilt Cylinder
Problem
- Finding: Cylinder Leaks Oil
- Recommendation: Remove Cylinder and Install New Seal Kit
Extension Cylinder
OK
Cross Bar
OK
Fork Receiver
Warning
- Finding: T bolts missing
- Recommendation: Install
Wrecker Main Frame
Free Of Cracks / Broken Welds
OK
Mounting Plate Condition
OK
Mounting Plate Bolts Tight
OK
Wrecker Boom
Check Each Boom Stage / Outer Tube For Straightness
Problem
- Finding: Boom is bent.
- Recommendation: T.b.d.
Boom Wear Pads
OK
Boom Free Of Cracks / Broken Welds
Problem
- Finding: Boom is cracking in various places.
- Recommendation: T.b.d.
Boom Extend Cylinder Operation
OK
Boom Pivot Pin
OK
Boom Lift Cylinder Pins
OK
Boom Lift Cylinders
Warning
- Finding: Cylinders may be seeping.
- Recommendation: Clean and inspect.
Hydraulic lines mounted under boom condition
Problem
- Finding: One line is seeping.
- Recommendation: Repair.
Wrecker Outrigger Legs
Wheel Lift Tire/Bus Lift
Tire Lift Shoes
Problem
- Finding: Missing
- Recommendation: Replace
Side In Arms
Problem
- Finding: Arms Damaged or Missing
- Recommendation: Replace Arms
Locking Pins for Tire Lift
Problem
- Finding: All pins missing
- Recommendation: Replace
Tire Lift Mounting Brackets
OK
Wheel Lift Tie Downs HD
Rachet
Warning
- Finding: Miss matched.
- Recommendation: Replace.
Wrecker Controls
Control Handles
OK
Control Cables
OK
Control Valve
OK
Wrecker Body Lighting
Side Marker Lights
Problem
- Finding: Inop
- Recommendation: Repair
Rear Tail/Brake Lights
Problem
- Finding: Tail lights inop
- Recommendation: Repair
Under Body Flood Lights
OK
Tool Box Interior Lights
Problem
- Finding: Inop
- Recommendation: Repair/Replace
Body Side Top Mounted Flood Lights
OK
Emergency Beacon Main
Warning
- Finding: Not working correctly.
- Recommendation: Repair.
Rear Facing Strobes
Problem
- Finding: Inop
- Recommendation: Diagnose
Hydraulic Hoses
Hydraulic Pump Hoses
Warning
- Finding: Suction hose cracking
- Recommendation: Noted.
Notes
- Technician's Notes: Hydraulic tank oil level sights are painted over.
Hydraulic Pump
Oil Leak
Warning
- Finding: Possibly leaking
- Recommendation: Clean and inspect
Hydraulic Pressure
OK
Remote Hydraulic Controls
Tow Light Kit
Wireless Tow Light Sender
Problem
- Finding: Missing
- Recommendation: Replace
Wireless Tow Light Housing
Warning
- Finding: Not working properly
- Recommendation: Repair or replace
Fenderettes
Mudflaps
Driver Side Mudflap
Problem
- Finding: Not zip’s mudflaps
- Recommendation: Replace
Passenger Side Mudflap
Problem
- Finding: Not Zip’s mudflaps
- Recommendation: Replace
Winch (Single)(Driver Side)
Gearbox Vent - Free of Paint & debris
OK
Free Wheel Mechanism
Problem
- Finding: Inop
- Recommendation: Diagnose and fix
Two Speed Winch Control System
Problem
- Finding: Two Speed Inoperative
- Recommendation: Repair Two Speed
Winch Mounting
OK
Cable Tensioner
Problem
- Finding: Inop
- Recommendation: Diagnose and fix
Winch Cable
Problem
- Finding: Cable is bad
- Recommendation: Replace
Winch Passenger Side (or Top Deck)
Oil Leak
OK
Gearbox Vent - Free of Paint & debris
OK
Free Wheel Mechanism
Problem
- Finding: Inop
- Recommendation: Diagnose and fix
Air Free Wheel Control
Problem
- Finding: Free Wheel Control System Inoperative
- Recommendation: Repair Free Wheel Control
Two Speed Winch Control System
Problem
- Finding: Two Speed Inoperative
- Recommendation: Repair Two Speed
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner Control
Problem
- Finding: Cable Tensioner Control Inoperative
- Recommendation: Fix control
Winch Cable
OK
Wrecker Body Condition
Overall Paint Condition
- Technician's Notes: Good.
Driver Side
- Technician's Notes: Good.
Tail Board
- Technician's Notes: Good.
Tool Box Doors
- Technician's Notes: No keys and some doors are missing hardware.
- Shocks are wore out.
Wrecker Standard Accessories
Tow Light Kit
Problem
- Technician's Notes: Incomplete.
Flare Kit
Problem
- Technician's Notes: Missing
Fire Extinguisher
Problem
- Technician's Notes: Missing
Safety Chains
Warning
- Finding: Not standard slip hook chains.
- Recommendation: T.b.d.
DOT Inspection Pass or Fail
Does This Unit Pass DOT Inspection?
Problem
- Technician's Notes: Steering needs work.
Austin Liddle, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.