Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com

Any questions? Please contact your service advisor, Randy Wickman.

Wrecker Tandem or Tri-Axle

Inspected on
5/19/2025 8:58 AM
Performed by
Jared Pitz
Customer
. .
Repair Order
J22717
Vehicle
2016 Kenworth T8 Series
VIN
1NKDL49X3GJ455895
License Plate
IA
Odometer
622,869mi

Pre-Trip In Cab Air Brake Test

Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI

OK OK icon.

Low Air Warning Device Sounds After Pressure Drops Under 55 PSI

OK OK icon.

Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds

Problem Problem icon.

  • Finding: Drops air pressure quickly
  • Recommendation: Find air leak and repair
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds

Problem Problem icon.

  • Finding: Find air air leak
  • Recommendation: Fix air leak
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes

OK OK icon.

Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi

OK OK icon.

Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi

OK OK icon.

Test Drive

Brake Stopping Distance

OK OK icon.

Cruise Control

OK OK icon.

Proper Acceleration and Engine Performance

OK OK icon.

Jake Brake Operation

OK OK icon.

Parking Brake

OK OK icon.

Wind Noise

OK OK icon.

Steering Wheel Alignment

OK OK icon.

Drive Straight (Does Not Pull)

Warning Warning icon.

  • Finding: Pulls right
  • Recommendation: Diagnose and fix
Brakes Evenly

OK OK icon.

Transmission Operation

OK OK icon.

Clutch Operation

OK OK icon.

Vibration

OK OK icon.

ECM Reading

Mileage on ECM

 icon.

  • Technician's Notes: 622869.390 miles
Engine Hours

16169 hrs

Computer Error Codes

Is The Check Engine Light Off?

Problem Problem icon.

Is The ABS Light Off?

OK OK icon.

Active ECM Error Codes

Tires

Check & Adjust Tire Pressures, Record PSI

 icon.

  • Technician's Notes: .
Left Front Tire

OK OK icon. 13 /32nds

Right Front Tire

OK OK icon. 15 /32nds

Left Rear Inner Tire (Axle 1)

OK OK icon. 15 /32nds

Left Rear Outside Tire (Axle 1)

OK OK icon. 16 /32nds

Left Rear Outside Tire (Axle 2)

OK OK icon. 15 /32

Left Rear Inner Tire (Axle 2)

OK OK icon. 15 /32

Right Rear Outside Tire (Axle 1)

OK OK icon. 15 /32nds

Right Rear Inside Tire (Axle 1)

OK OK icon. 15 /32nds

Right Rear Outside Tire (Axle 2)

OK OK icon. 16 /32

Right Rear Inside Tire (Axle 2)

OK OK icon. 16 /32

Brake Linings, Drums, Rotors & S-Cams

Left Front Brakes (Air)

OK OK icon.

Right Front Brakes (Air)

OK OK icon.

Left Rear Brakes (Drive Axle 1) Air

OK OK icon.

Right Rear Brakes (Drive Axle 1) Air

OK OK icon.

Left Rear Brakes (Drive Axle 2) Air

OK OK icon.

Right Rear Brakes (Drive Axle 2) Air

OK OK icon.

Shock Absorbers

Left Front Shock

OK OK icon.

Right Front Shock

OK OK icon.

Left Rear Wheel (Drive Axle 1) Shock

OK OK icon.

Right Rear Wheel (Drive Axle 1) Shock

OK OK icon.

Left Rear Wheel (Drive Axle 2) Shock

OK OK icon.

Right Rear Wheel (Drive Axle 2) Shock

OK OK icon.

Emergency Brakes

Brake Control Valve

OK OK icon.

Spring Brake Cannister

OK OK icon.

Wheels and Hardware

Left Front Rims

OK OK icon.

Right Front Rims

OK OK icon.

Left Rear Wheel (Drive Axle 1) Rims

OK OK icon.

Left Rear Wheel (Drive Axle 2) Rims

OK OK icon.

Right Rear Wheel (Drive Axle 2) Rims

OK OK icon.

Left Front Axle Studs

OK OK icon.

Right Front Axle Studs

OK OK icon.

Left Rear Wheel (Drive Axle 1) Axle Studs

OK OK icon.

Right Rear Wheel (Drive Axle 1) Axle Studs

OK OK icon.

Left Rear Wheel (Drive Axle 2) Axle Studs

OK OK icon.

Right Rear Wheel (Drive Axle 2) Axle Studs

OK OK icon.

Wheel Seals

Left Front Wheel Seal

OK OK icon.

Right Front Wheel Seal

OK OK icon.

Left Rear Wheel (Drive Axle 1) Wheel Seal

OK OK icon.

Right Rear Wheel (Drive Axle 1) Wheel Seal

OK OK icon.

Left Rear Wheel (Drive Axle 2) Wheel Seal

OK OK icon.

Right Rear Wheel (Drive Axle 2) Wheel Seal

OK OK icon.

Underhood

PTO Override Control Box - Test Electric & Air Override

OK OK icon.

Radiator

OK OK icon.

Radiator Cap

OK OK icon.

Coolant Level/Condition

OK OK icon.

Coolant/Heater Hoses

OK OK icon.

Battery

OK OK icon.

Battery Cables

OK OK icon.

Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting

OK OK icon. 2 Qty

Air Filter

OK OK icon.

Cabin Air Filter

OK OK icon.

More Information...

*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.

Fuel Filter - Primary

Problem Problem icon.

  • Finding: Filter change recommended
  • Recommendation: Change filter
Fuel Filter - Secondary

Problem Problem icon.

  • Finding: Filter change recommended
  • Recommendation: Change filter

Engine

Engine Oil Leaks

Problem Problem icon.

  • Finding: Clean and inspect for leaks
  • Recommendation: Inspect further
Doesn't Start

OK OK icon.

Engine Water Leaks

OK OK icon.

Motor Mounts

OK OK icon.

Turbo

OK OK icon.

Engine Performance

OK OK icon.

Engine Fan

Fan Blade Assembly

OK OK icon.

Air Operated Fan Clutch

OK OK icon.

Fan Shroud

OK OK icon.

Fan Belt

OK OK icon.

Air Compressor

Air Compressor

OK OK icon.

Block Heater

Block Heater

OK OK icon.

Power Steering

Power Steering Pump

OK OK icon.

Power Steering Hoses

OK OK icon.

Power Steering Oil Reservoir

OK OK icon.

Front Suspension HD

King Pins

OK OK icon.

Front Springs

OK OK icon.

Rear Suspension HD

Radius Arms

Problem Problem icon.

  • Finding: Passenger side front radius arm bushing bad.
  • Recommendation: Replace radius arm.
Rear Spring Shackles

OK OK icon.

No-Start - Cranks Over

Fuel Level

OK OK icon.

Battery Test

OK OK icon.

Charging/Starting/Battery Systems OLD

Battery Cables

OK OK icon.

Battery Charged?

OK OK icon.

Alternator Wiring

OK OK icon.

Warning Lights in Dash

Is The Check Engine Light Off?

Problem Problem icon.

  • Technician's Notes: NOx sensors.
Is The ABS Light Off?

OK OK icon.

Codes Appearing for Check Engine

 icon.

  • Technician's Notes: 1885, 3649.
Is The Water Temp Warning Light Off?

OK OK icon.

Chassis Lubrication

Greased King Pins

Problem Problem icon.

  • Finding: Need greased
  • Recommendation: Grease them
Greased Tie Rod Ends

Problem Problem icon.

  • Finding: Grease
  • Recommendation: Grease
Greased Springs

Problem Problem icon.

  • Finding: Need greased
  • Recommendation: Grease them
Greased Driveshaft Bearings

Problem Problem icon.

  • Finding: Grease
  • Recommendation: Grease
Engine Oil To Full Mark?

OK OK icon.

Oil Filled Hubs To Proper Level

OK OK icon.

Transmission Oil Level Full?

OK OK icon.

Rear Differential Oil Levels Full

OK OK icon.

Power Steering Oil Level Full

OK OK icon.

Windshield Washer Level Full?

OK OK icon.

Engine Coolant Level Full?

OK OK icon.

Engine Oil Filter Life

Problem Problem icon.

  • Finding: Needs changed
  • Recommendation: Change
Fuel Filter Life

Problem Problem icon.

  • Finding: Filter change recommended
  • Recommendation: Change
Air Dryer Filter

OK OK icon.

Anti-Freeze Test to -30

OK OK icon.

Steering Sector Oil Full

OK OK icon.

Chassis Lighting

Head Lamps

OK OK icon.

Hi/Low Head Lamp Switch

OK OK icon.

Factory Marker Lights

OK OK icon.

Turn Signal Lights

OK OK icon.

Interior Cab Courtesy Lights

OK OK icon.

In Dash Lights

OK OK icon.

4-Way Flashers

OK OK icon.

Back-Up Light

OK OK icon.

3-ID Lights

OK OK icon.

License Plate Light

OK OK icon.

Back Up Alarm

Warning Warning icon.

  • Finding: Inop
  • Recommendation: Diagnose and repair

Fuel System

Hoses

OK OK icon.

Fuel Pump

OK OK icon.

Fuel Fill System

OK OK icon.

Fuel Tanks

OK OK icon.

Fuel Tank Mounting Brackets

OK OK icon.

Transfer Case

Transfer Case

Warning Warning icon.

  • Finding: Possible leak
  • Recommendation: Diagnose issue
Transfer Case Mounting

OK OK icon.

Chassis Driveline

Hanger Bearings

OK OK icon.

Front Universal Joint

OK OK icon.

Rear Universal Joint

OK OK icon.

Intermediate Universal Joint

OK OK icon.

Transmission Yoke

OK OK icon.

Intermediate Yoke

OK OK icon.

Rear End Yoke

OK OK icon.

Dive Shaft Tube

OK OK icon.

Rear Differential #1

OK OK icon.

Rear Differential #2

OK OK icon.

Chassis Exterior Condition

Hood

Warning Warning icon.

  • Finding: Damaged
  • Recommendation: To be determined
Grille

OK OK icon.

Hood Latch

OK OK icon.

Cowl

OK OK icon.

Back of Cab

OK OK icon.

Left Cab Corner

OK OK icon.

Roof

OK OK icon.

Right Cab Corner

OK OK icon.

Drivers Door

OK OK icon.

Passenger Door

OK OK icon.

Left Fender

OK OK icon.

Right Fender

OK OK icon.

OEM Front Bumper

OK OK icon.

Fuel Tanks

OK OK icon.

Driver Side Cab Entry Steps

OK OK icon.

Passenger Side Cab Entry Steps

OK OK icon.

Chassis Interior Cab Components

Switch Panel

OK OK icon.

Driver Seat Cushion

OK OK icon.

Drive Seat Back

OK OK icon.

Driver Seat Suspension

OK OK icon.

Passenger Seat Cushion

OK OK icon.

Passenger Seat Back

OK OK icon.

Passenger Seat Suspension

OK OK icon.

Steering Wheel

OK OK icon.

Brake Pedal Pad

OK OK icon.

Clutch Pedal Pad

OK OK icon.

Instrument Cluster

OK OK icon.

Dash

OK OK icon.

Arm Rest

OK OK icon.

Driver Door Arm Rest

OK OK icon.

Passenger Door Arm Rest

OK OK icon.

Drivers Door Card

Warning Warning icon.

  • Finding: Fabric is separating.
  • Recommendation: T.b.d.
Passenger Door Card

OK OK icon.

Driver Side Electric/Air Window

OK OK icon.

Passenger Side Electric/Air Window

Warning Warning icon.

  • Finding: Will not go up on its own
  • Recommendation: Diagnose and repair
Driver Door Handle

OK OK icon.

Passenger Door Handle

OK OK icon.

Floor Mat

OK OK icon.

Air Horn

OK OK icon.

Horn (on Steering Wheel)

OK OK icon.

Shifter Boot

OK OK icon.

Air Vents

Warning Warning icon.

  • Finding: One broken vent
  • Recommendation: Replace
Drivers Door Hinge

OK OK icon.

Passenger Door Hinge

OK OK icon.

Seat Belts

OK OK icon.

Engine Idle Up While Parked, Cruise Switch

OK OK icon.

Exhaust

Muffler

OK OK icon.

Flex Tubing

OK OK icon.

Elbows

OK OK icon.

Tubing

OK OK icon.

Engine Manifold

OK OK icon.

Exhaust Mounting Brackets

OK OK icon.

Manual Transmission

Shifting Operation

OK OK icon.

Clutch Operation

OK OK icon.

Throw-Out Bearing Noise

OK OK icon.

Oil Leaks

Warning Warning icon.

  • Finding: Trans is wet with oil in various spots.
  • Recommendation: Diagnose and repair
Bell Housing

OK OK icon.

Input Shaft

OK OK icon.

Frame Components

Frame Rails

OK OK icon.

Glass

Windshield

OK OK icon.

Left Door Glass

OK OK icon.

Right Door Glass

OK OK icon.

Rear Window

OK OK icon.

Mirrors

Left Mirror

Warning Warning icon.

  • Finding: Electric mirror not working properly.
  • Recommendation: Fix or replace
Right Mirror

Warning Warning icon.

  • Finding: Power mirror not working properly.
  • Recommendation: Fix or replace

Windshield Wipers

Left Wiper

OK OK icon.

Right Wiper

OK OK icon.

Wiper Switch

OK OK icon.

Washer Tank

OK OK icon.

Radio

Radio Tuner

OK OK icon.

Radio Speaker

OK OK icon.

Sleeper

Mattress

OK OK icon.

Steering Heavy Duty

Steering Wheel Centered Properly

OK OK icon.

Tie Rod Ends

OK OK icon.

Drag Link

OK OK icon.

Pitman Arm

OK OK icon.

Steering Column

OK OK icon.

Steering Sector

OK OK icon.

Power Steering Oil Lines

Warning Warning icon.

  • Finding: Oil reservoir leaving tank are damp
  • Recommendation: Clean and inspect

Alternator

Alternator

OK OK icon.

Alternator Mount

OK OK icon.

Air Conditioning

Air Conditioning Performance

OK OK icon.

Air Conditioning Compressor

OK OK icon.

Receiver Dryer

OK OK icon.

Air Conditioning Hoses

OK OK icon.

Freon Level

OK OK icon.

Air Dryer

Air Dryer

OK OK icon.

Cab Heater

Heater Controls

OK OK icon.

Fan Motor

OK OK icon.

Chassis Gauges

Oil Pressure

OK OK icon.

Water Temperature

OK OK icon.

Rear End #1 Temperature Gauge

OK OK icon.

Main Air Pressure Gauge

OK OK icon.

Secondary Air Pressure Gauge

OK OK icon.

Tachometer

OK OK icon.

Speedometer

OK OK icon.

Odometer

OK OK icon.

Rear End #2 Temperature Gauge

OK OK icon.

Fuel Gauge

OK OK icon.

DEF Fluid Gauge

OK OK icon.

Camera

Factory Rear Camera

Warning Warning icon.

  • Finding: Did not turn on
  • Recommendation: Diagnose and fix
Aftermarket Camera

Warning Warning icon.

  • Finding: Did not turn on
  • Recommendation: Diagnose and fix
Notes

 icon.

  • Technician's Notes: No screen inside cab for rear cameras

Power Take-Off

PTO Mounting Bolts To Transmission

OK OK icon.

Oil Leak From Main Shaft

Warning Warning icon.

  • Finding: Possible leak
  • Recommendation: Inspect and repair
PTO Noisey

OK OK icon.

Air Leak At PTO

OK OK icon.

PTO Shift Mechanism

OK OK icon.

Wheel Lift

Wear Pads

OK OK icon.

Pivot Pin

Warning Warning icon.

  • Finding: Froze up
  • Recommendation: Repair
Lift Cylinder

OK OK icon.

Tilt Cylinder

OK OK icon.

Extension Cylinder

OK OK icon.

Inner Stinger

OK OK icon.

Cross Bar

OK OK icon.

Outer Tube

Warning Warning icon.

  • Finding: End has a dent/bent
  • Recommendation: Repair
Wheel-Lift Hold Down Straps

OK OK icon.

Wheel-lift Forks (Number of Sets)

9 Qty

Fork Receiver

OK OK icon.

Notes

 icon.

  • Technician's Notes: Some stop blocks missing and broken bolts

Wrecker Main Frame

Free Of Cracks / Broken Welds

OK OK icon.

Mounting Plate Condition

OK OK icon.

Mounting Plate Bolts Tight

OK OK icon.

Wrecker Boom

Check Each Boom Stage / Outer Tube For Straightness

OK OK icon.

Boom Wear Pads

OK OK icon.

Boom Free Of Cracks / Broken Welds

OK OK icon.

Boom Extend Cylinder Operation

OK OK icon.

Boom Pivot Pin

OK OK icon.

Boom Lift Cylinder Pins

OK OK icon.

Boom Lift Cylinders

OK OK icon.

Hydraulic lines mounted under boom condition

OK OK icon.

Wrecker Outrigger Legs

Driver's Side Rear Outrigger

OK OK icon.

Passenger Side Rear Outrigger

OK OK icon.

Wheel Lift Tire/Bus Lift

Tire Lift Shoes

OK OK icon.

Side In Arms

OK OK icon.

Locking Pins for Tire Lift

OK OK icon.

Tire Lift Mounting Brackets

OK OK icon.

Wheel Lift Tie Downs HD

Rachet

OK OK icon.

Wheel-Lift Tie Down Strap For Tire Lift

OK OK icon.

Wrecker Controls

Control Handles

OK OK icon.

Control Cables

OK OK icon.

Remote Control

OK OK icon.

Control Valve

OK OK icon.

Elevated Idle Switch

Warning Warning icon.

  • Finding: Doesn't work in the control box.
  • Recommendation: Diagnose

Wrecker Body Lighting

Side Marker Lights

Warning Warning icon.

  • Finding: Many lights are inop.
  • Recommendation: Repair/replace.
Rear Tail/Brake Lights

OK OK icon.

Under Body Flood Lights

OK OK icon.

Pylon Mounted Flood Lights

OK OK icon.

Tool Box Interior Lights

Warning Warning icon.

  • Finding: Some lights are inop
  • Recommendation: Repair/replace
Body Side Top Mounted Flood Lights

OK OK icon.

Side Mounted Flood/Area Lights

Warning Warning icon.

  • Finding: Inop
  • Recommendation: Repair
Side Mounted Specialty Lighting

Warning Warning icon.

  • Finding: A few lights out
  • Recommendation: Repair
Pylon Mounted Strobe Lights

OK OK icon.

Cab Mounted Marker Lights

OK OK icon.

Rear Facing Strobes

OK OK icon.

Side Facing Strobes

OK OK icon.

Wrecker Body Lubrication

Notes

 icon.

  • Technician's Notes: Grease everything

Hydraulic Hoses

Winch Hose Leaks

OK OK icon.

Wheel-Lift Tilt Cylinder Hose Leaks

OK OK icon.

Hydraulic Pump Hoses

OK OK icon.

Wheel-lift Extension Hoses

OK OK icon.

Control Valve Hose To Tank

OK OK icon.

Hydraulic Pump

Oil Leak

OK OK icon.

Hydraulic Pressure

OK OK icon.

Check & Record Hydraulic Pressure Reading(S)

 icon.

  • Technician's Notes: 3,000

Remote Hydraulic Controls

Remote Control Hand Held Unit

OK OK icon.

Wiring At Control Valve

OK OK icon.

Control Valve Solenoid

OK OK icon.

Tow Light Kit

Magnetic Tow Light Cord

OK OK icon.

Light Module

Warning Warning icon.

  • Finding: Light bulb inop
  • Recommendation: Replace
Heavy Duty Connecting Cord

OK OK icon.

Fenderettes

Driver Side Fenderette

OK OK icon.

Passenger Side Fenderette

OK OK icon.

Mudflaps

Driver Side Mudflap

Warning Warning icon.

  • Finding: Non-zip mudflaps
  • Recommendation: Replace with zip mudflaps
Passenger Side Mudflap

Warning Warning icon.

  • Finding: Non-zip mudflaps
  • Recommendation: Replace with zip mudflaps

Emergency Lighting

Switch Panel

OK OK icon.

Main Beacon Light

OK OK icon.

Right Side Auxiliary Beacon

OK OK icon.

Left Side Auxiliary Beacon

OK OK icon.

Winch (Single)(Driver Side)

Oil Leak

OK OK icon.

Gearbox Vent - Free of Paint & debris

OK OK icon.

Grease Free Spool Linkage

OK OK icon.

Oil Level In Gearbox

Warning Warning icon.

  • Finding: Low
  • Recommendation: Fill
Free Wheel Mechanism

OK OK icon.

Air Free Wheel Control

OK OK icon.

Two Speed Winch Control System

OK OK icon.

Winch Gearbox Drive Mechanism

OK OK icon.

Winch Mounting

OK OK icon.

Cable Tensioner

OK OK icon.

Cable Tensioner Control

OK OK icon.

Winch Cable

Warning Warning icon.

  • Finding: Pull out and inspect cable
  • Recommendation: Replace if necessary

Winch Passenger Side (or Top Deck)

Oil Leak

OK OK icon.

Grease Free Spool Linkage

OK OK icon.

Change Oil In Gearbox

Warning Warning icon.

  • Finding: Oil low
  • Recommendation: Top off
Gearbox Vent - Free of Paint & debris

OK OK icon.

Free Wheel Mechanism

OK OK icon.

Air Free Wheel Control

OK OK icon.

Two Speed Winch Control System

OK OK icon.

Winch Gearbox Drive Mechanism

OK OK icon.

Winch Mounting

OK OK icon.

Cable Tensioner

OK OK icon.

Cable Tensioner Control

OK OK icon.

Winch Cable

Warning Warning icon.

  • Finding: Pull out and inspect cable
  • Recommendation: Replace if necessary

Wrecker Body Condition

Overall Paint Condition

Tail Board

Light Pylon

OK OK icon.

Wrecker Standard Accessories

Tow Light Kit

OK OK icon.

Fire Extinguisher

OK OK icon.

Safety Chains

OK OK icon.

Snatch Blocks

Quantity of Snatch Blocks

 icon. 0 Qty

  • Technician's Notes: Missing

Truck Hitch

Slide Arms

OK OK icon.

Cross Bar

Warning Warning icon.

  • Finding: Locking pins missing
  • Recommendation: Replace
Cam Locks Or Plunger Pins

OK OK icon.

Jared Pitz, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.

Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.