Zip's Truck Equipment
316 W. Milwaukee St.
New Hampton, IA 50659
(641) 394-3166
zips.com
Any questions? Please contact your service advisor, Randy Wickman.
Carrier Inspection Air Brake SA Diesel Auto
- Inspected on
- 2/3/2026 8:25 AM
- Performed by
- Charlie Westervelt
- Customer
- . .
- Repair Order
- J22984
- Vehicle
- 2020 International MV
- VIN
- 1HTEUMMLXLH563863
- License Plate
- IA
- Odometer
- 146,430mi
Pre-Trip In Cab Air Brake Test
Parking Brake Test- Fully Charged Air System, Engine Off & Parking Brakes Released. Apply Service Brakes Several Times To Bleed Air System Down. Parking Brakes Should Activate Between 45-20 PSI
OK
Low Air Warning Device Sounds After Pressure Drops Under 55 PSI
OK
Air Loss Rate Test - Single- Release Parking Brake & Apply Service Brakes For 60 Seconds & Hold. Must Not Lose More Than 2 psi after Initial Loss After 60 Seconds
OK
Air Leakage Static Check - Single - With Fully Charged Air System (120psi) & Engine Off, Parking Brakes Released, Pressure Can Not Drop Greater Than 2 psi after 60 seconds
OK
Air Pressure Build Up Test - Compressor Must Increase PSI From 85 to 100 In Less Than 2 Minutes
OK
Governor Cut Out Test - Governor Must Cut Out At A Minimum Of 100 psi & Maximum 145 psi
OK
Governor Cut In Test - Governor Must Cut In Within 25 psi of Cut Out psi
OK
Test Drive
Brake Stopping Distance
OK
Proper Acceleration and Engine Performance
OK
Parking Brake
OK
Wind Noise
OK
Steering Wheel Alignment
Warning
- Finding: Not centerd
- Recommendation: Adjust
Drive Straight (Does Not Pull)
Warning
- Finding: Pulls
- Recommendation: Check Tires and Alignment
Brakes Evenly
OK
Transmission Operation
OK
Vibration
OK
ECM Reading
Mileage on ECM
- Technician's Notes: 146434
Engine Hours
7184 hrs
Computer Error Codes
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Active ECM Error Codes
Tires
Check & Adjust Tire Pressures, Record PSI
- Technician's Notes: 112
Visible Tire Alignment Wear
OK
Left Front Tire
OK
Right Front Tire
OK
Left Rear Inner Tire (Axle 1)
OK
Left Rear Outside Tire (Axle 1)
OK
Right Rear Outside Tire (Axle 1)
OK
Right Rear Inside Tire (Axle 1)
OK
Brake Linings, Drums, Rotors & S-Cams
Left Front Brakes (Air)
OK
Right Front Brakes (Air)
OK
Left Rear Brakes (Drive Axle 1) Air
OK
Right Rear Brakes (Drive Axle 1) Air
OK
Brake Lines, Chambers & Adjusters
Left Front Wheel Brake LInes
OK
Right Front Wheel Brake Lines
OK
Left Rear Wheel (Drive Axle 1) Brake Lines
OK
Right Rear Wheel (Drive Axle 1) Brake Lines
OK
Left Front Brake Chamber
OK
Right Front Brake Chamber
OK
Left Rear Wheel (Drive Axle 1) Brake Chamber
OK
Right Rear Wheel(Drive Axle 1)Brake Chamber
OK
Left Front Wheel Bearing
OK
Right Front Wheel Bearing
OK
Left Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Right Rear Wheel (Drive Axle 1) Wheel Bearing
OK
Left Front Brake Slack Adjuster
OK
Right Front Brake Slack Adjuster
OK
Left Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Right Rear Wheel(D.A.1)Brake Slack Adjuster
OK
Shock Absorbers
Left Front Shock
OK
Right Front Shock
OK
Left Rear Wheel (Drive Axle 1) Shock
OK
Right Rear Wheel (Drive Axle 1) Shock
OK
Emergency Brakes
Brake Control Valve
OK
Spring Brake Cannister
OK
Wheels and Hardware
Left Front Rims
OK
Right Front Rims
OK
Left Rear Wheel (Drive Axle 1) Rims
OK
Right Rear Wheel (Drive Axle 1) Rims
OK
Left Front Axle Studs
OK
Right Front Axle Studs
OK
Left Rear Wheel (Drive Axle 1) Axle Studs
OK
Right Rear Wheel (Drive Axle 1) Axle Studs
OK
Stainless Steel Wheel Simulators
Left Front Wheel
Problem
- Finding: Missing
- Recommendation: Replace
Right Front Wheel
Problem
- Finding: Missing
- Recommendation: Replace
Left Rear Wheel (Drive Axle 1)
Problem
- Finding: Missing
- Recommendation: Replace
Right Rear Wheel (Drive Axle 1)
Problem
- Finding: Missing
- Recommendation: Replace
Wheel Seals
Left Front Wheel Seal
OK
Right Front Wheel Seal
OK
Left Rear Wheel (Drive Axle 1) Wheel Seal
OK
Right Rear Wheel (Drive Axle 1) Wheel Seal
OK
Underhood
Radiator
OK
Radiator Cap
OK
Engine Oil Level/Condition
Warning
- Finding: full but black
- Recommendation: change oil
Power Steering Fluid Condition
OK
Transmission Fluid Condition
OK
Coolant Level/Condition
OK
Coolant/Heater Hoses
OK
Battery
OK
Battery Cables
OK
Serpentine / Drive Belt - Must not show more than 5 cracks per inch, chunking, rib glazing, backside wear or splitting
OK
Air Filter
OK
Cabin Air Filter
Warning
- Finding: Filter Dirty
- Recommendation: Clean
*** The cabin Filter is what cleans the air that you breathe inside the car. It can contain mold, mildew and debris. This can degrade the air quality in the cabin of the vehicle.
Fuel Filter - Primary
Warning
- Finding: Filter change recommended
- Recommendation: Change filter
Fuel Filter - Secondary
Warning
- Finding: Filter change recommended
- Recommendation: Change filter
Engine
Engine Oil Leaks
Warning
- Finding: Damp on the bottom of the bell housing.
- Recommendation: Clean and inspect
Doesn't Start
OK
Engine Water Leaks
OK
Motor Mounts
OK
Turbo
OK
Glow Plugs
OK
Manifold Heater
OK
Engine Performance
OK
Crank Case Ventilation Filter (change if > 60,000 miles)
Warning
- Finding: Filter change recommended
- Recommendation: Change filter
Engine Fan
Fan Blade Assembly
OK
Air Operated Fan Clutch
OK
Fan Shroud
OK
Fan Belt
OK
Air Compressor
Air Compressor
OK
Block Heater
Block Heater
OK
Power Steering
Power Steering Pump
OK
Power Steering Hoses
OK
Power Steering Oil Reservoir
OK
Front Suspension HD
King Pins
Problem
- Finding: Both king pins need replaced
- Recommendation: Replace
Front Springs
OK
Air Bag Suspension
OK
Rear Suspension HD
Rear Springs
OK
Radius Arms
OK
Rear Spring Shackles
OK
Air Bag Suspension Operation
OK
Charging/Starting/Battery Systems OLD
Battery Cables
OK
Battery Charged?
OK
Alternator Wiring
OK
Warning Lights in Dash
Is The Check Engine Light Off?
OK
Is The ABS Light Off?
OK
Codes Appearing for Check Engine
Is The Water Temp Warning Light Off?
OK
Chassis Lubrication
Engine Oil To Full Mark?
OK
Oil Filled Hubs To Proper Level
OK
Transmission Oil Level Full?
OK
Rear Differential Oil Levels Full
Warning
- Finding: Low
- Recommendation: Fill back to proper level
Power Steering Oil Level Full
OK
Windshield Washer Level Full?
OK
Engine Coolant Level Full?
OK
Engine Oil Filter Life
Warning
- Finding: Needs to be changed with the oil
- Recommendation: Change it
Fuel Filter Life
Warning
- Finding: Filter life unknown
- Recommendation: Replace filter
Air Dryer Filter
OK
Anti-Freeze Test to -30
OK
Chassis Lighting
Head Lamps
OK
Hi/Low Head Lamp Switch
OK
Factory Marker Lights
Problem
- Finding: A few lights out on wrecker body.
- Recommendation: Repair or replace.
Turn Signal Lights
OK
Interior Cab Courtesy Lights
OK
In Dash Lights
OK
4-Way Flashers
OK
Back-Up Light
Problem
- Finding: Alarm inop no lights
- Recommendation: Diagnose and repair
3-ID Lights
OK
License Plate Light
OK
Back Up Alarm
Problem
- Finding: Does Not Work
- Recommendation: Repair / Replace
Fuel System
Hoses
OK
Fuel Pump
OK
Fuel Fill System
OK
Fuel Tanks
Warning
- Finding: Rubber missing
- Recommendation: Replace
Fuel Tank Mounting Brackets
OK
Automatic Transmission
Operation
OK
Oil Leaks
OK
Filter
OK
Chassis Driveline
Hanger Bearings
OK
Front Universal Joint
OK
Rear Universal Joint
OK
Intermediate Universal Joint
OK
Transmission Yoke
OK
Intermediate Yoke
OK
Rear End Yoke
OK
Dive Shaft Tube
OK
Rear Differential #1
OK
Chassis Exterior Condition
Hood
OK
Grille
OK
Hood Latch
OK
Hood Springs
OK
Cowl
OK
Left Cab Corner
OK
Roof
OK
Right Cab Corner
OK
Drivers Door
Warning
- Finding: Key lock spins and doesn’t unlock door
- Recommendation: Repair/replace
Passenger Door
OK
Left Fender
OK
Right Fender
OK
OEM Front Bumper
OK
Fuel Tanks
OK
Driver Side Cab Entry Steps
OK
Passenger Side Cab Entry Steps
Warning
- Finding: Bent
- Recommendation: Straighten
Chassis Interior Cab Components
Switch Panel
OK
Driver Seat Cushion
Problem
- Finding: Lots of rips and missing some foam
- Recommendation: Repair seat
Drive Seat Back
OK
Driver Seat Suspension
OK
Passenger Seat Cushion
OK
Passenger Seat Back
OK
Steering Wheel
OK
Brake Pedal Pad
OK
Instrument Cluster
OK
Dash
OK
Arm Rest
OK
Driver Door Arm Rest
OK
Passenger Door Arm Rest
OK
Drivers Door Card
OK
Passenger Door Card
OK
Driver Side Electric/Air Window
Problem
- Finding: Master switch broken
- Recommendation: Replace
Passenger Side Electric/Air Window
OK
Driver Door Lock
OK
Passenger Door Lock
OK
Driver Door Handle
OK
Passenger Door Handle
OK
Floor Mat
OK
Horn (on Steering Wheel)
OK
Shifter Boot
OK
Air Vents
OK
Drivers Door Hinge
OK
Passenger Door Hinge
OK
Seat Belts
OK
Engine Idle Up While Parked, Cruise Switch
OK
Exhaust
Muffler
OK
Flex Tubing
OK
Elbows
Warning
- Finding: Damaged or Leaking Elbows
- Recommendation: Thghtened clamp
Tubing
OK
Engine Manifold
OK
Exhaust Mounting Brackets
OK
DPF System
DPF Warning Light
OK
Exhaust Fluid Level
Warning
- Finding: Half tank
- Recommendation: Top off
Frame Components
Frame Rails
OK
Glass
Windshield
Problem
- Finding: Windshield is Cracked
- Recommendation: Replace Windshield
Left Door Glass
OK
Right Door Glass
OK
Rear Window
OK
Mirrors
Left Mirror
OK
Spot Mirrors
OK
Windshield Wipers
Left Wiper
OK
Right Wiper
OK
Wiper Switch
OK
Washer Tank
OK
Radio
Radio Tuner
OK
Radio Speaker
OK
Steering Heavy Duty
Steering Wheel Centered Properly
Warning
- Finding: Needs alignment.
- Recommendation: Align
Tie Rod Ends
OK
Drag Link
OK
Pitman Arm
OK
Steering Column
OK
Steering Sector
OK
Power Steering Oil Lines
OK
Alternator
Alternator
OK
Alternator Mount
OK
Air Conditioning
Air Conditioning Performance
OK
Air Conditioning Compressor
OK
Air Compressor Belt
OK
Receiver Dryer
OK
Air Conditioning Hoses
OK
Freon Level
OK
Air Dryer
Air Dryer
OK
Cab Heater
Heater Controls
OK
Fan Motor
OK
Fan
OK
Chassis Gauges
Oil Pressure
OK
Water Temperature
OK
Transmission Oil Temperature
OK
Main Air Pressure Gauge
OK
Secondary Air Pressure Gauge
OK
Tachometer
OK
Speedometer
OK
Odometer
OK
Air Filter Gauge
OK
Low Air Pressure Warning Buzzer
OK
PTO Warning Light
OK
Fuel Gauge
OK
DEF Fluid Gauge
OK
Intake Manifold Heater
OK
Power Take-Off
PTO Mounting Bolts To Transmission
OK
PTO Warning Light
OK
Oil Leak From Main Shaft
OK
PTO Noisey
OK
Air Leak At PTO
OK
PTO Shift Mechanism
OK
Wheel Lift
Wear Pads
Warning
- Finding: Need replaced
- Recommendation: Replace
Pivot Pin
OK
Lift Cylinder
OK
Extension Cylinder
OK
Left L-Arm
OK
Right L-Arm
OK
Left Slide Tray
OK
Right Slide Tray
OK
Inner Stinger
OK
Cross Bar
OK
Outer Tube
OK
Carrier Body Lighting
Cab Mounted Marker Lights
OK
Control Station Lights
Problem
- Finding: Both sides inop
- Recommendation: Replace
Emergency Main Beacon Lightbar
OK
Lower Work Lights
OK
Rear Tail / Brake Lights
OK
Rear Turn Signals
OK
Side Marker Lights
Warning
- Finding: passenger side marker light out
- Recommendation: Replace
Stop Tail Turn Lights In Beacon
OK
Upper Work Lights
OK
Winch Mounted Work Lights
OK
Carrier Body Lubrication
Sub-Frame And Long Sill Lubrication
Problem
- Finding: Needs greased
- Recommendation: Grease
Tilt Cylinder Pins
Warning
- Finding: Needs greased
- Recommendation: Grease
Hydraulic Filter
Warning
- Finding: In Need of Service Because of Age
- Recommendation: Install New Filter
Hydraulic Fluid
OK
Winch Oil Level
OK
Extension Cylinder Pins
OK
Main Bed Pivot Pin At Rear
Problem
- Finding: Needs greased
- Recommendation: Grease
Car Carrier Steel Deck
Steel Deck Floor Condition
OK
Steel Deck Cross Members
OK
Deck Outer Rail
OK
Long Sill
OK
Rear Approach Plate
OK
Carrier Steel Deck Floor Paint Condition
Paint on Floor
Warning
- Finding: Has some rust
- Recommendation: Repaint if desired
Carrier Hydraulic Cylinders
Tilt Cylinders
OK
Bed Extension Cylinder
OK
Car Carrier Bed Hold-Down
Frame Mounted Hold Down
Problem
- Finding: Bed locks bent and wheels need replace
- Recommendation: Replace
Car Carrier Removable Rails
Steel Rails
OK
Car Carrier Tail Light Housing
Driver Side Tail Light Housing
Warning
- Finding: Loose, stainless panel is bent
- Recommendation: Tighten, straighten
Passenger Side Tail light housing
Warning
- Finding: Rusty
- Recommendation: Need paint
Car Carrier Controls
Driver Side Control Levers
OK
Passenger Side Control Levers
OK
Control Valve
Warning
- Finding: Control Valve Leaking
- Recommendation: Clean and diagnose
Control Station Decal
OK
Valve Pressure
OK
Driver Side Control Box
OK
Passenger Side Control Box
OK
Anti-Tilt Plate
OK
Cross Over Control Housing
OK
Red Arrow - Bed Tilt Decal
Problem
- Finding: Missing
- Recommendation: Replace
Car Carrier Tool Box
Passenger Side Front Box
Warning
- Finding: Box is rusty
- Recommendation: To be deturmined
Passenger Side Rear Box
Warning
- Finding: Rusty
- Recommendation: Replace if desired
Hydraulic Hoses
General/Unknown Hose Leaks
- Technician's Notes: Main pressure line leak
Winch Hose Leaks
OK
Bed Lift Cylinder Hose Leaks
Problem
- Finding: Hose Leaks
- Recommendation: Replace Hose
Bed Extension Cylinder Hoses
OK
Wheel-Lift Tilt Cylinder Hose Leaks
OK
Hydraulic Pump Hoses
OK
Wheel-lift Extension Hoses
OK
Control Valve Hose To Tank
OK
Car Carrier Wiring
Carrier Wiring Dangling
OK
Bed Wiring Intermittant
OK
Wiring In Hose Tray
OK
Junction Box
OK
Hydraulic Pump
Oil Leak
OK
Hydraulic Pressure
OK
Tow Light Kit
Magnetic Tow Light Cord
Problem
- Finding: Missing
- Recommendation: Replace
Light Module
Problem
- Finding: Missing tow light
- Recommendation: Replace
Mudflaps
Driver Side Mudflap
OK
Passenger Side Mudflap
OK
Car Carrier Pylon
Pylon Center Cab Protector
Warning
- Finding: Bent
- Recommendation: Straighten
Pylon Paint Condition
OK
Emergency Lighting
Switch Panel
OK
Main Beacon Light
OK
Winch (Single)(Driver Side)
Oil Leak
Warning
- Finding: Gear Lube Leaking at Motor Coupling
- Recommendation: Remove Motor and Replace Winch Seal
Change Oil In Gearbox
OK
Oil Level In Gearbox
OK
Free Wheel Mechanism
OK
Winch Gearbox Drive Mechanism
OK
Winch Mounting
OK
Cable Tensioner
OK
Winch Cable
Problem
- Finding: Cable fraying
- Recommendation: Replace
Carrier Standard Accessories
J-Chains In Vehicle
Problem
- Technician's Notes: None
V-Chain Or V-Strap In Vehicle
Problem
- Technician's Notes: Broken
Tow Light Kit In Vehicle
Problem
- Technician's Notes: Lights not working
Fire Extinguisher in Vehicle
OK
Safety Chains
OK
Vehicle Tie Down Strap Kit
Problem
- Technician's Notes: None
Charlie Westervelt, A Certified Technician has made this inspection; it reflects the car's condition on this day and does not imply a warranty on the items checked. This inspection should only be used as an aid. This inspection does not mean that there were no other problems, but only what we noticed or what appeared at the time of inspection. Certain items may need further inspection to determine the extent of damage and cost.
Please contact Zip's Truck Equipment at (641) 394-3166 for more information about your Vehicle inspection.